CORROSION PREVENTIVE COMPOUND, AEROSOL

Material Safety Data Sheet

SECTION I - Material Identity
SECTION II - Manufacturer's Information
SECTION III - Physical/Chemical Characteristics
SECTION IV - Fire and Explosion Hazard Data
SECTION V - Reactivity Data
SECTION VI - Health Hazard Data
SECTION VII - Precautions for Safe Handling and Use
SECTION VIII - Control Measures
SECTION IX - Label Data
SECTION X - Transportation Data
SECTION XI - Site Specific/Reporting Information
SECTION XII - Ingredients/Identity Information

SECTION I - Material Identity

`Item Name`
`Part Number/Trade Name`	`ZRC COLD GALVANIZING COMPOUND (AEROSOL)`
`National Stock Number`	`8030010151550`
`CAGE Code`	`07957`
`Part Number Indicator`	`D`
`MSDS Number`	`128913`
`HAZ Code`	`B`

SECTION II - Manufacturer's Information

`Manufacturer Name`	`Z R C PRODUCTS CO`
`P.O. Box`	`N/K`
`Street`	`21 NEWPORT AVE`
`City`	`QUINCY`
`State`	`MA`
`Country`	`US`
`Zip Code`	`02171`
`Emergency Phone`	`800-424-9300 CHEMTREC/617-328-6700`
`Information Phone`	`617-328-6700`

MSDS Preparer's Information

`MSDS Preparer Name`	`STEVE COLLINS`
`Street`	`21 NEWPORT AVENUE`
`City`	`QUINCY`
`State`	`MA`
`Zip Code`	`02171`
`Date MSDS Prepared/Revised`	`27FEB92`
`Date of Technical Review`	`14AUG92`
`Active Indicator`	`N`
`Item Manager`	`GSA`

Alternate Vendors

`Vendor #1 Name`	`STEVEN INDUSTRIES`
`Vendor #1 CAGE`	`33150`
`Vendor #5 CAGE`	`BNTNV`

SECTION III - Physical/Chemical Characteristics

`Specification Number`	`N/K`
`Specification Type/Grade/Class`	`N/K`
`Hazard Storage Compatibility Code`	`N/-K`
`NRC License Number`	`N/K`
`Net Propellant Weight (Ammo)`	`N/K`
`Appearance/Odor`	`GREY LIQ W/ODOR TYPICAL OF ALIPHATIC & AROMATIC HYDROCARBONS MIXED W/KETONE`
`Boiling Point`	`-42 TO 144C`
`Melting Point`	`N/K`
`Vapor Pressure`	`50 @ 21C`
`Vapor Density`	`> AIR`
`Specific Gravity`	`1.14 @ 25C`
`Decomposition Temperature`	`N/K`
`Evaporation Rate`	`FASTER THAN ETHER`
`Solubility in Water`	`INSIGNIFICANT`
`Percent Volatiles by Volume`	`59(WT)`
`Chemical pH`	`N/K`
`Corrosion Rate`	`N/K`
`Container Pressure Code`	`4`
`Temperature Code`	`8`
`Product State Code`	`U`

SECTION IV - Fire and Explosion Hazard Data

`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`0.9 (VOL)`
`Upper Explosion Limit`	`66.4 (VOL)`
`Extinguishing Media`	`CLASS B EXTINGSHR, FOAM, DRY CHEM. DONT USE WTR] USE FULL PROTECT EQUIP & SCBA IN ENCLOSURES. HIGHLY FLAMM/MOD EXPLOS`
`Special Fire Fighting Procedures`	`DONT USE WATER IN ANY FORM. WATER MAY BE USED TO COOL CLSD CNTNRS, BUT TAKE CARE TO PREVENT WATER ACCESS TO WET PAINT & SPRAY RESIDUES. SEE SPILL SECTION`
`Unusual Fire/Explosion Hazards`	`KEEP CNTNR CLSD. ISOLATE FROM HEAT/IGNIT. APPLIC TO HOT SRFC REQ CAUTION. OVEREXPOS TO DECOMP-HLTH HZD. HEAVIER THAN AIR, FLOW TO DISTANT IGNIT SOURCE/FLASHBCK*`

SECTION V - Reactivity Data

`Stability`	`YES`
`Stability Conditions to Avoid`	`STORE IN DRY AREAS AWAY FROM OXIDIZING AGENTS, ACIDS, ALKALIES, & WATER. AVOID DUSTING & ACCUMULATION OF SPRAY RESIDUES`
`Materials to Avoid`	`MAY REACT VIOLENTLY W/STRONG OXIDIZING AGENTS SUCH AS CHLORINE, OXYGEN, WATER, WEAK OR CONCENTRATED ACIDS`
`Hazardous Decomposition Products`	`HYDROGEN GAS ACCOMPANIED W/ADDED RISK OF EXPLOSION/FIRE. FUMES OF ZINC OXIDES, OXIDES OF CARBON & NITROGEN`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`SENSITIVITY TO IMPACT: IMPACT W/SPARKING MAY PRODUCE DISCHARGE OF CONTENTS WITH FIRE OR EXPLOSION HAZARD`
`LD50 - LD50 Mixture`	`N/K`

SECTION VI - Health Hazard Data

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`PROPANE IS ASPHYXIANT. SOLVENTS IN MAT'L ARE CENTRAL NERVOUS SYSTEM DEPRESSANTS (DROWSINESS, DIZZINESS, HEADACHE, SLURRED SPEECH, INTOXICATION W/EUPHORIA/DEPRESSION, STUPOR, UNCONSCIOUSNESS) INHAL: NOSE, THROAT, LUNG IRRIT. SKIN: DEFATTING, DERMATITIS. EYE: TEARS, BURNING, IRRITATION, CONJUNCTIVITIS. **`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`N/K*MOISTR & ACID CONTAM CAN FORM HYDROGEN GAS, CAUSE CANS TO BULGE. DON'T MOVE, OPEN, PUNCTURE CANS. CALL 617-328-6700`
`Symptoms of Overexposure`	`** INGEST: POISONING, MAY BE FATAL; AVOID ASPIRATION. LUNG CONTACT MAY CAUSE CHEMICAL PNEUMONITIS. EXCESSIVE INHAL: FUME FEVER, ZINC SHAKES, ETC. REPEAT/PROLONG OVEREXPOSE: PERMANENT BRAIN, CENTRAL NERVOUS SYSTEM DAMAGE. MINOR EMBRYOTOXIC/FETOTOXIC EFFECTS (RATS). MAY CAUSE ALLERGIC SKIN REACTION`
`Medical Cond. Aggrevated by Exposure`	`N/K`
`Emergency/First Aid Procedures`	`INHAL: REMOVE TO FRESH AIR. KEEP WARM, QUIET. GIVE ARTIF RESPIRATION IF REQUIRED. GET MED AID. EYES: WASH IMMED WITH LARGE AMOUNT WATER 15 MIN. TAKE TO PHYSICIAN FOR MED AID. SKIN: WASH CONTACT AREA PROMPTLY W/SOAP & WATER. PROMPTLY REMOVE PAINT-WET CLOTHING. CONSULT PHYSICIAN IF IRRIT PERSISTS. INGEST: DO NOT INDUCE VOMITING WITHOUT MEDICAL ADVICE. SEE PHYSICIAN, EMERGENCY ROOM, POISON CTR IMMED`

SECTION VII - Precautions for Safe Handling and Use

`Steps if Material Released/Spilled`	`LRG: EVAC AREA. ALL SPILLS: ELIMINATE IGNIT SOURCES. DIKE, CONTAIN W/DRY, INERT MAT'L. ELIMINATE MOISTURE SOURCES. DONT USE WATER IN CLEANUP OPERATIONS. RECOVER FREE LIQ. USE ABSORB FOR REST. DONT FLUSH W/WATER. USE NONSPARK TOOLS. SPILLS-SLIPPERY`
`Neutralizing Agent`	`N/K`
`Waste Disposal Method`	`DISPOSE OF ABSORBED MAT'L/FREE WASTE LIQ IN DRY CNTNRS ACCORDING TO LOCAL, STATE & FED REGS. DISPOSE OF MAT'LS INCLUDING EMPTY CANS ACCORDING TO FED, STATE & LOCAL REGS. DONT INCINERATE. DONT FLUSH INTO SEWERS. CNTNRS MAY EXPLOD W/HEAT (EVEN EMPTY)`
`Handling and Storage Precautions`	`NONSPARK TOOLS. VENT USE AREAS. EXCLUDE IGNIT SOURCE/HEAT. NO SMOKING IN THESE AREAS. PREVENT ACCUMULATION (SUFF VENT)OF VAPOR IN LOW AREAS/SUMPS. MA`
`Other Precautions`	`MAT'L IS ELECTRICALLY CONDUCTIVE. FLAMM LIQ. STORE IN COOL, CLEAN DRY, VENTED, FIRE RESISTANT(MEET OSHA REQ) AREA. DONT STORE IN DIRECT SUNLIGHT. STORE IN CLSD LABELED CANS (LABELS SPECIFY FLAMMABILITY). DONT STORE ABOVE 49C. ***`

SECTION VIII - Control Measures

`Respiratory Protection`	`OUTDOOR/OPEN AREAS: NIOSH/MSHA RSPRTR (FILTER DUST PARTIC) DURING & AFTER APPLIC (UNLESS BELOW TLV). RESTRICT VENT: NIOSH/MSHA RSPRTR (COMBINATN ORGANIC VAPOR, DUST PARTIC). CONFINED: AIR LINE TYPE RSPRTR/HOOD. FOLLOW RSPRTR MFRS DIRECTIONS`
`Ventilation`	`WORK PLACE AREAS REQUIRE EXHAUST VENT IN ACCORDANCE W/OSHA REGULATIONS 29CFR1910.107D TO MAINTAIN LEVELS BELOW TLV`
`Protective Gloves`	`NEOPRENE GLOVES`
`Eye Protection`	`SFTY GOGGLES W/UNPERFORATED SIDE SHIELD#`
`Other Protective Equipment`	`WEAR NEOPRENE APRONS OVER FITTED CLOTHES,CHEM RESISTANT BOOTS W/STEEL TOES,PROTECTIVE CREAM,EYEWASH FOUNTAIN,SFTY SHOWER`
`Work Hygenic Practices`	`OBSERVE ALL RULES OF GOOD HYGIENE DURING & AFTER USE. WASH BEFORE SMOKING OR EATING. WASH/DISCARD CONTAM CLOTHING`
`Supplemental Health/Safety Data`	`*** DONT INGEST. DONT PUNCTURE, DRAG OR SLIDE CNTNR. KEEP AWAY FROM CHILDREN. EMPTY CONTAINERS MAY CONTAIN EXTREMELY FLAMMABLE RESIDUES AND EXPLODE IF HEATED. #SHOULD BE USED WHERE SPLASHING INTO EYES IS POSSIBLE`
`Disposal Code`	`O`

SECTION IX - Label Data

`Protect Eye`	`NO`
`Protect Skin`	`NO`
`Protect Respiratory`	`NO`
`Chronic Indicator`	`UNKNOWN`
`Contact Code`	`UNKNOWN`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`

SECTION X - Transportation Data

`Container Quantity`	`12`
`Unit of Measure`	`OZF`

SECTION XI - Site Specific/Reporting Information

SECTION XII - Ingredients/Identity Information

`Ingredient #`	`01`
`Ingredient Name`	`METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 75 MM @ 20C) (LEL 1.8)`
`CAS Number`	`78933`
`NIOSH Number`	`EL6475000`
`Proprietary`	`NO`
`Percent`	`35`
`OSHA PEL`	`200 PPM/300 PPM STEL`
`ACGIH TLV`	`200 PPM/300 PPM STEL`
`Recommended Limit`	`OSHA TWA 50 PPM`
`Ingredient #`	`02`
`Ingredient Name`	`(ZNCPD) ZINC (SARA III)`
`CAS Number`	`7440666`
`NIOSH Number`	`ZG8600000`
`Proprietary`	`NO`
`Percent`	`37.4`
`OSHA PEL`	`TWA 50 PPM/15 MG/M3*`
`ACGIH TLV`	`NOT ESTABLISHED`
`Recommended Limit`	`*(TOTAL DUST)`
`Ingredient #`	`03`
`Ingredient Name`	`(ZNCPD) ZINC OXIDE`
`CAS Number`	`1314132`
`NIOSH Number`	`ZH4810000`
`Proprietary`	`NO`
`Percent`	`1.6`
`OSHA PEL`	`15MG/M3 TDUST/5 FUME`
`ACGIH TLV`	`10MG/M3 TDUST; 9293`
`Recommended Limit`	`FUME *DUST`
`Ingredient #`	`04`
`Ingredient Name`	`XYLENE (SARA III) (VAPOR PRESSURE 6 MM @ 20 C) (LEL 1.0)`
`CAS Number`	`1330207`
`NIOSH Number`	`ZE2100000`
`Proprietary`	`NO`
`Percent`	`10`
`OSHA PEL`	`100 PPM/150 PPM STEL`
`ACGIH TLV`	`100 PPM/150 PPM STEL`
`Recommended Limit`	`NONE SPECIFIED`
`Ingredient #`	`05`
`Ingredient Name`	`VM & P NAPHTHA (VAPOR PRESSURE 2 MM @ 20C) (LEL 0.9)`
`CAS Number`	`8032324`
`NIOSH Number`	`OI6180000`
`Proprietary`	`NO`
`Percent`	`<5`
`OSHA PEL`	`300 PPM/400 STEL`
`ACGIH TLV`	`300 PPM`
`Recommended Limit`	`NONE SPECIFIED`
`Ingredient #`	`06`
`Ingredient Name`	`PROPANE (VAPOR PRESSURE 123 PSIA @ 20C) (LEL 2.3)`
`CAS Number`	`74986`
`NIOSH Number`	`TX2275000`
`Proprietary`	`NO`
`Percent`	`15`
`OSHA PEL`	`1000 PPM/1800 MG/M3`
`ACGIH TLV`	`SMPL ASPHYXIANT`
`Recommended Limit`	`NONE SPECIFIED`