MSDS Information

Material Safety Data Sheet

SECTION I - Material Identity
SECTION II - Manufacturer's Information
SECTION III - Physical/Chemical Characteristics
SECTION IV - Fire and Explosion Hazard Data
SECTION V - Reactivity Data
SECTION VI - Health Hazard Data
SECTION VII - Precautions for Safe Handling and Use
SECTION VIII - Control Measures
SECTION IX - Label Data
SECTION X - Transportation Data
SECTION XI - Site Specific/Reporting Information
SECTION XII - Ingredients/Identity Information

SECTION I - Material Identity

`Part Number/Trade Name`	`NON-SHRINK GENERAL PURPOSE GROUT, 5902-51`
`National Stock Number`	`561000N070724`
`CAGE Code`	`QUIKR`
`Part Number Indicator`	`A`
`MSDS Number`	`181413`
`HAZ Code`	`B`

SECTION II - Manufacturer's Information

`Manufacturer Name`	`QUIKRETE COMPANIES`
`Street`	`1790 CENTURY CIRCLE`
`City`	`ATLANTA`
`State`	`GA`
`Country`	`US`
`Zip Code`	`30345`
`Emergency Phone`	`404-634-9100`
`Information Phone`	`404-634-9100`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`14APR94`
`Date of Technical Review`	`18APR96`
`Active Indicator`	`N`

Alternate Vendors

Vendor #5 CAGE

BZSRS

SECTION III - Physical/Chemical Characteristics

`Appearance/Odor`	`WHITE TO GRAY-NO ODOR`
`Boiling Point`	`N/K`
`Melting Point`	`N/K`
`Vapor Pressure`	`N/K`
`Vapor Density`	`N/K`
`Specific Gravity`	`N/K`
`Decomposition Temperature`	`N/K`
`Evaporation Rate`	`N/K`
`Solubility in Water`	`SUPDAT`
`Percent Volatiles by Volume`	`N/K`
`Chemical pH`	`N/K`
`Corrosion Rate`	`N/K`
`Container Pressure Code`	`4`
`Temperature Code`	`8`
`Product State Code`	`U`

SECTION IV - Fire and Explosion Hazard Data

`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`N/K`
`Upper Explosion Limit`	`N/K`
`Extinguishing Media`	`MEDIA SUITABLE FOR SURROUNDING FIRE (FP N)`
`Special Fire Fighting Procedures`	`USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE EQUIPMENT (FP N)`
`Unusual Fire/Explosion Hazards`	`NONCOMBUSTIBLE AND NOT EXPLOSIVE`

SECTION V - Reactivity Data

`Stability`	`YES`
`Stability Conditions to Avoid`	`NONE SPECIFIED BY MANUFACTURER`
`Materials to Avoid`	`CONTACT WITH POWERFUL OXIDIZING AGENTS SUCH AS FLUORINE, CHLORINE TRIFLUORIDE, MANGANESE TRIOXIDE, OXYGEN (SUPDAT)`
`Hazardous Decomposition Products`	`SILICA WILL DISSOLVE IN HYDROFLUORIC ACID AND PRODUCE A CORROSIVE GAS-SILICON TETRAFLUORIDE`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`NOT RELEVANT`
`LD50 - LD50 Mixture`	`NONE SPECIFIED BY MANUFACTURER`

SECTION VI - Health Hazard Data

`Route of Entry: Skin`	`NO`
`Route of Entry: Ingestion`	`NO`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`EXPOSURE TO RESPIRABLE CRYSTALLINE QUARTZ MAY CAUSE DELAYED (CHRONIC) LUNG DISEASE (SILICOSIS); ACUTE ORRAPIDLY DEVELOPING SILICOSIS MAY OCCUR IN A SHORT PERIOD OF TIME IN HEAVY EXPOSURE IN CERTAIN OCCUPATIONS SUCH AS SANDBLASTERS WHEN PROPER SAFETY RESPIRATORS ARE NOT UTILIZED BY SANDBLASTER/USER. (EFTS OF OVEREXP)`
`Carcinogenity: NTP`	`YES`
`Carcinogenity: IARC`	`YES`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`SILICA, CRYSTALLINE-QUARTZ:IARC MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH ANNUAL REPORT ON (SUPDAT)`
`Symptoms of Overexposure`	`HLTH HAZ:SILICOSIS IS A FORM OF DISABLING PULMONARY FIBROSIS WHICH CAN BE PROGESSIVE AND MAY LEAD TO DEATH. UNDUE BREATHLESSNESS, WHEEZING, COUGH, AND SPUTUM PRODUCTION`
`Medical Cond. Aggrevated by Exposure`	`PULM FUNCTION MAY BE REDUCED BY INHAL OF RESPIRABLE CRYSTALLINE SILICA. ALSO LUNG SCARRING PRODUCED BY SUCH INHAL MAY LEAD TO A PROGRESSIVE MASSIVE FIBROSIS OF THE LUNG (SILICOSIS) WHICH MAY (SUPDAT)`
`Emergency/First Aid Procedures`	`INGEST: CALL MD IMMEDIATELY (FP N). EYES: IRRIGATE (FLOOD) EYES IMMEDIATELY AND REPEATEDLY WITH CLEAN WATER FOR AT LEAST 15 MINUTES. SKIN: WASH EXPOSED SKIN AREAS WITH SOAP AND WATER. IF IRRITATION OR INFLAMMATION OCCURS SEEK PROMPT MEDICAL ATTENTION. INHAL: REMOVE PERSON IMMEDIATELY TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION AS NEEDED. GET PROMPT MEDICAL ATTENTION`

SECTION VII - Precautions for Safe Handling and Use

`Steps if Material Released/Spilled`	`IF SPILLED, USE DUSTLESS METHODS (VACUUM) AND PLACE INTO CLOSABLE CONTAINER FOR DISPOSAL OR FLUSH WITH WATER. DO NOT DRY SWEEP. WEAR PROTECTIVE EQUIPMENT SPECIFIED`
`Neutralizing Agent`	`NONE SPECIFIED BY MANUFACTURER`
`Waste Disposal Method`	`CAN BE TREATED AS A COMMON WASTE FOR DISPOSAL IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS`
`Handling and Storage Precautions`	`CUSTOMERS-USERS MUST COMPLY WITH ALL APPLICABLE HEALTH AND SAFETY LAWS, REGULATIONS AND ORDERS COVERING SILICA`
`Other Precautions`	`NONE SPECIFIED BY MANUFACTURER`

SECTION VIII - Control Measures

`Respiratory Protection`	`IN DUSTY ENVIRONMENTS, THE USE OF AN OSHA, MSHA OR NIOSH APPROVED RESPIRATOR IS RECOMMENDED`
`Ventilation`	`LOCAL EXHAUST CAN BE USED, IF NECESSARY, TO CONTROL AIRBORNE DUST LEVELS`
`Protective Gloves`	`IMPERVIOUS GLOVES (FP N)`
`Eye Protection`	`ANSI APPROVED CHEM WORKERS GOGGS (FP N)`
`Other Protective Equipment`	`EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEETANSI DESIGN CRITERIA (FP N)`
`Work Hygenic Practices`	`NONE SPECIFIED BY MANUFACTURER`
`Supplemental Health/Safety Data`	`SOL IN H*2O: INSOLUBLE TO SLIGHTLY SOLUBLE IN WATER. MATLS TO AVOID: DIFLUORIDE, MAY CAUSE FIRES. MED CNDTNS:AGGRAVATE OTHER PULMONARY CONDITIONS & DISEASE & WHICH INCREASE SUSCEPTIBILITY TO PULMONARY FAILURE. SMOKING AGGRAVATES THE EFTS OF EXPOSURE. EXPLAN OF CARCIN: CARCINOGENS, 1994: ANTICIAPTED TO BE CARCIN`

SECTION IX - Label Data

`Protect Eye`	`NO`
`Protect Skin`	`NO`
`Protect Respiratory`	`NO`
`Chronic Indicator`	`UNKNOWN`
`Contact Code`	`UNKNOWN`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`

SECTION X - Transportation Data

`Container Quantity`	`80`
`Unit of Measure`	`LB`

SECTION XI - Site Specific/Reporting Information

`Volatile Organic Compounds (P/G)`	`0`
`Volatile Organic Compounds (G/L)`	`0`

SECTION XII - Ingredients/Identity Information

`Ingredient #`	`01`
`Ingredient Name`	`SILICA, CRYSTALLINE - QUARTZ; (SILICA SAND, CRYSTALLINE)`
`CAS Number`	`14808607`
`NIOSH Number`	`VV7330000`
`Proprietary`	`NO`
`Percent`	`N/K`
`OSHA PEL`	`SEE TABLE Z-3`
`ACGIH TLV`	`0.1 MG/M3 RDUST;9495`
`Recommended Limit`	`N/K`
`Ingredient #`	`02`
`Ingredient Name`	`CALCIUM (II) SULFATE, DIHYDRATE (1:1:2); (GYPSUM)`
`CAS Number`	`10101414`
`NIOSH Number`	`EW4150000`
`Proprietary`	`NO`
`Percent`	`N/K`
`OSHA PEL`	`15 MG/M3 TDUST`
`ACGIH TLV`	`10 MG/M3 TDUST; 9495`
`Recommended Limit`	`N/K`
`Ingredient #`	`03`
`Ingredient Name`	`AMORPHOUS SILICA (FROM FLY ASH OR MICRO SILICA)`
`CAS Number`	`7631869`
`NIOSH Number`	`VV7310000`
`Proprietary`	`NO`
`Percent`	`N/K`
`OSHA PEL`	`80 MG/M3 %SIO*2(MFR)`
`ACGIH TLV`	`N/K (FP N)`
`Recommended Limit`	`N/K`
`Ingredient #`	`04`
`Ingredient Name`	`CALCIUM CARBONATE; (PULVERIZED LIMESTONE)`
`CAS Number`	`1317653`
`NIOSH Number`	`EV9580000`
`Proprietary`	`NO`
`Percent`	`N/K`
`OSHA PEL`	`5 MG/M3 (MFR)`
`ACGIH TLV`	`5 MG/M3 (MFR)`
`Recommended Limit`	`N/K`
`Ingredient #`	`05`
`Ingredient Name`	`ALUMINUM (POWDER)`
`CAS Number`	`7429905`
`NIOSH Number`	`BD0330000`
`Proprietary`	`NO`
`Percent`	`N/K`
`OSHA PEL`	`5 MG/M3 (MFR)`
`ACGIH TLV`	`5 MG/M3 (MFR)`
`Recommended Limit`	`N/K`