| Item Name | |
| Part Number/Trade Name | ABS PLASTIC PIPE CEMENT |
| National Stock Number | 8040P773 |
| CAGE Code | 53472 |
| Part Number Indicator | A |
| MSDS Number | 186036 |
| HAZ Code | B |
| Manufacturer Name | OATEY COMPANY |
| P.O. Box | 35906 |
| Street | 4700 W 160TH STREET |
| City | CLEVELAND |
| State | OH |
| Zip Code | 44135 |
| Emergency Phone | 303-623-5716 |
| Information Phone | 303-623-5716 |
| Date MSDS Prepared/Revised | 17FEB86 |
| Date of Technical Review | 15JAN89 |
| Active Indicator | N |
| Hazard Storage Compatibility Code | NR |
| NRC License Number | NR |
| Net Propellant Weight (Ammo) | NR |
| Appearance/Odor | BLACK LIQUID.SHARP,FRAGRANT,MINT-LIKE ODOR |
| Boiling Point | 176 F |
| Melting Point | NR |
| Vapor Pressure | 100 |
| Vapor Density | 2.5 |
| Specific Gravity | 0.85 |
| Decomposition Temperature | NR |
| Evaporation Rate | 2.7 (ETHER=1) |
| Solubility in Water | 27.1% WT |
| Percent Volatiles by Volume | 78% |
| Chemical pH | NA |
| Corrosion Rate | NR |
| Container Pressure Code | 1 |
| Temperature Code | 4 |
| Product State Code | L |
| Flash Point | 20 |
| Flash Point Method | TCC |
| Lower Explosion Limit | 2 |
| Upper Explosion Limit | 12 |
| Extinguishing Media | SMALL FIRES:DRY CHEMICAL,CARBON DIOXIDE, WATER ORFOAM.LARGE FIRES:EVACUATE AREA & CALL FIRE DEPARTMENT IMMEDIATELY |
| Special Fire Fighting Procedures | USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT (FP N) |
| Unusual Fire/Explosion Hazards | CARBON DIOXIDE,CARBON MONOXIDE AND BLACK SMOKE ARE HAZARDOUS DECOMPOSITION PRODUCTS |
| Stability | YES |
| Stability Conditions to Avoid | HEAT,SPARKS AND OPEN FLAME |
| Materials to Avoid | ACIDS,OXIDIZING MATERIALS,ALKALIS,CHLORINATED INORGANICS (POTASSIUM,CALCIUM & SODIUM HYPOCHLORITE),COPPER OR ITS ALLOYS |
| Hazardous Decomposition Products | CARBON MONOXIDE,CARBON DIOXIDE,BLACK SMOKE |
| Hazardous Polymerization | NO |
| Polymerization Conditions to Avoid | WILL NOT OCCUR |
| LD50 - LD50 Mixture | N/K |
| Route of Entry: Skin | YES |
| Route of Entry: Ingestion | YES |
| Route of Entry: Inhalation | YES |
| Health Hazards - Acute and Chronic | CHRONIC CONTACT OR EXPOSURE TO VAPORS OF HIGH CONCENTRATIONS MAY CAUSE DERMATITIS.REPRODUCTIVE,NERVOUS SYSTEM AND LUNG TOXIN.CONCENTRATION OF 1000-3000 PPM CAUSED RETARDATION OF FETAL DEVELOPMENT IN RATS |
| Carcinogenity: NTP | NO |
| Carcinogenity: IARC | NO |
| Carcinogenity: OSHA | NO |
| Explanation of Carcinogenity | NONE |
| Symptoms of Overexposure | EYES:IRRITATION.SKIN:IRRITATION AND DERMATITIS.INGEST/INHAL:CENTRAL NERVOUS SYSTEM DEPRESSION.IRRITATION OF MUCOUS MEMBRANESOF NOSE &/OR THROAT.HEADACHE,DIZZINESS,NUMBNESS OF THE EXTREMITIES AND NARCOSIS |
| Medical Cond. Aggrevated by Exposure | N/K |
| Emergency/First Aid Procedures | EYES:FLUSH WITH PLENTY OF H*2O FOR AT LEAST 15 MIN.GET MED ATTN.SKIN:FLUSH W/ H*2O,& WASH THOROUGHLY W/ SOAP & H*2O.REMOVE CONTAM CLTHG,WASH BEFORE REUSE.CALL MD/POISON CONTROL CENTER IF IRRIT PERSISTS.INGEST:IF CONSCIOUS,GIVE PLENTY OF H*2O.DO NOT INDUCE VOMITING.AVOID ASPIRATION.CALL MD/POISON CONTROL CENTER.AVOID ALCOHOL.INHAL:MOVE TO FRESH AIR.GIVE O*2/ARTF RESP.KEEP WARM & QUIET.GET MD IMMED |
| Steps if Material Released/Spilled | VENTILATE AREA,STOP LEAK IF IT CAN BE DONE WITHOUT RISK.TAKE UP WITH SAND,EARTH OR OTHER ABSORBING MATERIAL |
| Neutralizing Agent | N/K |
| Waste Disposal Method | DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,STATEAND LOCAL REGULATIONS |
| Handling and Storage Precautions | KEEP AWAY FROM HEAT,SPARKS AND FLAMES.STORE IN A COOL,DRY PLACE |
| Other Precautions | HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL DUE TO RETENTION OF PRODUCT RESIDUE AND VAPORS |
| Respiratory Protection | NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN |
| Ventilation | LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR CONCENTRATION BELOW TLV |
| Protective Gloves | RUBBER GLOVES |
| Eye Protection | CHEMICAL WORKERS GOGGLES |
| Other Protective Equipment | EYE WASH AND SAFETY SHOWER |
| Work Hygenic Practices | N/K |
| Supplemental Health/Safety Data | WILL DISSOLVE IN ORGANIC SOLVENTS |
| Protect Eye | YES |
| Protect Skin | YES |
| Protect Respiratory | YES |
| Chronic Indicator | YES |
| Contact Code | UNKNOWN |
| Fire Code | UNKNOWN |
| Health Code | UNKNOWN |
| React Code | UNKNOWN |
| Specific Hazard and Precaution | TARGET ORGANS: CENTRAL NERVOUS SYSTEM, REPRODUCTIVE SYSTEM, RESPIRATORY SYSTEM |
| Container Quantity | 1 |
| Unit of Measure | PT |
| Volatile Organic Compounds (P/G) | 5.424 |
| Volatile Organic Compounds (G/L) | 650 |
| Ingredient # | 01 |
| Ingredient Name | CARBON BLACK (<1%) |
| CAS Number | 1333864 |
| Proprietary | NO |
| Percent | 1 |
| OSHA PEL | 3.5 MG/M3 |
| ACGIH TLV | 3.5 MG/M3 |
| Ingredient # | 02 |
| Ingredient Name | METHYL ETHYL KETONE (65-75%) |
| CAS Number | 78933 |
| Proprietary | NO |
| Percent | 75 |
| OSHA PEL | 200 PPM/300 STEL |
| ACGIH TLV | 200 PPM/300STEL 9192 |
| Ingredient # | 03 |
| Ingredient Name | ABS RESIN (20-30%) |
| CAS Number | 9003569 |
| Proprietary | NO |
| Percent | 30 |
| OSHA PEL | N/K (FP N/ORNL) |
| ACGIH TLV | N/K (FP N/ORNL) |
| Ingredient # | 04 |
| Ingredient Name | FUMED SILICA (<1%) |
| CAS Number | 7631869 |
| Proprietary | NO |
| Percent | 1 |
| Ingredient # | 05 |
| Ingredient Name | CYCLOHEXANONE (4-8%) |
| CAS Number | 108941 |
| Proprietary | NO |
| Percent | 8 |