30756 OATEY PURPLE PRIMER NSF

Material Safety Data Sheet

SECTION I - Material Identity
SECTION II - Manufacturer's Information
SECTION III - Physical/Chemical Characteristics
SECTION IV - Fire and Explosion Hazard Data
SECTION V - Reactivity Data
SECTION VI - Health Hazard Data
SECTION VII - Precautions for Safe Handling and Use
SECTION VIII - Control Measures
SECTION IX - Label Data
SECTION X - Transportation Data
SECTION XI - Site Specific/Reporting Information
SECTION XII - Ingredients/Identity Information

SECTION I - Material Identity

`Item Name`
`Part Number/Trade Name`	`30755-30759, & 30927 OATEY PURPLE PRIMER NSF`
`National Stock Number`	`6850P30756`
`CAGE Code`	`53472`
`Part Number Indicator`	`A`
`MSDS Number`	`192878`
`HAZ Code`	`B`

SECTION II - Manufacturer's Information

`Manufacturer Name`	`OATEY CO`
`P.O. Box`	`35906`
`Street`	`4700 WEST 160TH STREET`
`City`	`CLEVELAND`
`State`	`OH`
`Country`	`US`
`Zip Code`	`44135`
`Emergency Phone`	`303-623-5716 / 800-424-9300`
`Information Phone`	`216-267-7100`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`30DEC02`
`Active Indicator`	`Y`

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Appearance/Odor`	`PURPLE LIQUID, SHARP ETHER ODOR`
`Boiling Point`	`174F/66C`
`Melting Point`	`NA`
`Vapor Pressure`	`70`
`Vapor Density`	`2.5`
`Specific Gravity`	`.84`
`Evaporation Rate`	`5.5-8.0`
`Solubility in Water`	`28 PARTS`
`Percent Volatiles by Volume`	`99.96`
`Chemical pH`	`NA`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

SECTION IV - Fire and Explosion Hazard Data

`Flash Point`	`0`
`Flash Point Method`	`PMCC`
`Lower Explosion Limit`	`1.8`
`Upper Explosion Limit`	`11.5`
`Extinguishing Media`	`[SMALL] USE DRY CHEMICAL, CO2, WATER OR FOAM EXTINGUISHER. [LARGE] EVACUATE AREA AND CALL FIRE DEPARTMENT IMMEDIATELY`
`Special Fire Fighting Procedures`	`NR`
`Unusual Fire/Explosion Hazards`	`NR`

SECTION V - Reactivity Data

`Stability`	`YES`
`Stability Conditions to Avoid`	`HEAT, SPARKS AND OPEN FLAME`
`Materials to Avoid`	`ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM, CALCIUM AND SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS`
`Hazardous Decomposition Products`	`CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE, SMOKE`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`

SECTION VI - Health Hazard Data

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`[INHAL] MAY CAUSE IRRITATION OF MUCOUS MEMBRANES, NOSE & THROAT, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF THE EXTREMITIES AND NARCOSIS IN HIGH CONCENTRATIONS. HAS CAUSED CNS DEPRESSION & LIVER DAMAGE. [SKIN] CHRONIC CONTACT MAY LEAD TO IRRITATION & DERMATITIS. CHRONIC EXPOSURE TO VAPORS OF HIGH CONCENTRATION MAY CAUSE DERMATITIS. MAY BE ABSORBED THROUGH SKIN. [SYS] VAPORS OR DIRECT CONTACT MAY CAUSE IRRITATION [INGEST] MAY BE ASPIRATED INTO THE LUNGS OR CAUSE SYSTEMIC EFFECTS DESCRIBED IN INHALE`
`Symptoms of Overexposure`	`SEE ABOVE`
`Medical Cond. Aggrevated by Exposure`	`NR`
`Emergency/First Aid Procedures`	[SKIN] IF IRRITATION ARISES, WAHS THOROUGHLY WITH SOAP AND WATER. SEEK MED ATTENTION IF IRRITATION PERSISTS. [EYES] IF FUMES CAUSE IRRITATION, MOVE TO FRESH AIR AND IRRIGATE EYES WITH WATER FOR 15 MIN. IF IRRITATION PERSISTS, SEEK MED ATTEN. [INHAL] MOVE TO FRESH AIR. GIVE OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. KEEP VICTIM QUIET AND WARM. CALL A POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELY. [INGEST] DRINK WATER AND CALL A POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELY. AVOID ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON

SECTION VII - Precautions for Safe Handling and Use

`Steps if Material Released/Spilled`	`VENTILATE AREA, STOP LEAK IF IT CAN BE DONE WITHOUT RISK. TAKE UP WITH SAND, EARTH , OR OTHER NON COMBUSTIBLE ABSORBING MATERIAL`
`Waste Disposal Method`	`DISPOSE ACCORDING TO LOCAL , STATE, AND FEDERAL REGULATIONS`
`Handling and Storage Precautions`	`KEEP AWAY FROM HEAT, SPARKS, AND FLAMES. STORE IN COOL , DRY PLACE`
`Other Precautions`	`CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE AND VAPOR`

SECTION VIII - Control Measures

`Respiratory Protection`	`NIOSH APPROVED CANISTER RESPIRATOR IN ABSENCE OF ADEQUATE VENTILATION`
`Ventilation`	`OPEN DOORS& WINDOWS. LOCAL EXHAUST`
`Protective Gloves`	`RUBBER GLOVES`
`Eye Protection`	`SAFETY GLASSES WITH SIDE SHIELDS`
`Other Protective Equipment`	`EYE WASH WITH SAFTY SHOWER`
`Work Hygenic Practices`	`WASH THOROUGHLY AFTER HANDLING`

SECTION IX - Label Data

`Protect Eye`	`NO`
`Protect Skin`	`NO`
`Protect Respiratory`	`NO`
`Chronic Indicator`	`UNKNOWN`
`Contact Code`	`UNKNOWN`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`

SECTION X - Transportation Data

SECTION XI - Site Specific/Reporting Information

`Volatile Organic Compounds (P/G)`	`6.2584`
`Volatile Organic Compounds (G/L)`	`749.9994`

SECTION XII - Ingredients/Identity Information

`Ingredient #`	`01`
`Ingredient Name`	`2-PROPANONE`
`CAS Number`	`67641`
`Percent`	`1`
`Ingredient #`	`02`
`Ingredient Name`	`CYCLOHEXANONE`
`CAS Number`	`108941`
`Percent`	`20`
`Ingredient #`	`03`
`Ingredient Name`	`FURAN, TETRAHYDRO-`
`CAS Number`	`109999`
`Percent`	`15`
`Ingredient #`	`04`
`Ingredient Name`	`2-BUTANONE`
`CAS Number`	`78933`
`Percent`	`80`
`Ingredient #`	`05`
`Ingredient Name`	`VIOLET DYE (NON HAZARDOUS)`
`CAS Number`	`81481`
`Percent`	`1`
`Ingredient #`	`06`
`Ingredient Name`	`RED DYE( NON HAZARDOUS)`
`CAS Number`	`4477796`
`Percent`	`1`