FLUX, SOLDERING

Material Safety Data Sheet

MSDS Preparer's Information

Alternate Vendors

Vendor #5 CAGE

BCVGR

`Specification Number`	`MIL-F-14256`
`Specification Type/Grade/Class`	`TYPE R`
`Hazard Storage Compatibility Code`	`F3-F2`
`NRC License Number`	`NR`
`Net Propellant Weight (Ammo)`	`NR`
`Appearance/Odor`	`AMBER STICKY LIQUID WITH ALCOHOL ODOR`
`Boiling Point`	`170F`
`Melting Point`	`NA`
`Vapor Pressure`	`40`
`Vapor Density`	`1.8`
`Specific Gravity`	`0.880`
`Decomposition Temperature`	`NR`
`Evaporation Rate`	`1.8`
`Solubility in Water`	`59%`
`Percent Volatiles by Volume`	`66.0`
`Chemical pH`	`NA`
`Corrosion Rate`	`NR`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

`Flash Point`	`65`
`Flash Point Method`	`TOC`
`Lower Explosion Limit`	`2.0`
`Upper Explosion Limit`	`12.0`
`Extinguishing Media`	`CARBON DIOXIDE, ALCOHOL FOAM, DRY CHEMICAL`
`Special Fire Fighting Procedures`	`USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS AND CONTROL VAPORS`
`Unusual Fire/Explosion Hazards`	`A MODERATE EXPLOSION HAZARD EXISTS WHEN EXPOSED TO HEAT OR FLAME`

`Stability`	`YES`
`Stability Conditions to Avoid`	`NE`
`Materials to Avoid`	`STRONG OXIDIZING AMTERIALS`
`Hazardous Decomposition Products`	`LIBERATE ALIPHATIC ALDEHYDES, ACIDS, AND TERPENES`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`NE`
`LD50 - LD50 Mixture`	`NR`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`PROLONGED OR REPEATED SKIN CONTACT CAN RESULT IN A RASH. BREATHING VAPORS CAN RESULT IN HEADACHE, DIZZINESS, NARCOSIS AND IRRITATION OF THE MUSCOUS MEMBRAMES. SMOKE DURING SOLDERING CAN CAUSE RESPIRATORY SYSTEM IRRITATION AND DAMAGE`
`Carcinogenity: NTP`	`NR`
`Carcinogenity: IARC`	`NR`
`Carcinogenity: OSHA`	`NR`
`Explanation of Carcinogenity`	`NONE`
`Symptoms of Overexposure`	`INHALATION: FUMES DURING SOLDERING MAY IRRITATE MUSCOUS MEMBRAMES AND RESPIRATORY SYSTEM. HIGH CONCENTRATIONS CAN CAUSE HEADACHE, DIZZINESS, NARCOSIS AND NAUSEA SKIN: LOCAL IRRITATION EYE: IRRITATION INGESTION: BURNING SENSATION IN THE DIGESTIVE TRACT`
`Medical Cond. Aggrevated by Exposure`	`CHEMICAL HYPERSENSITIVITY, ASTHMA AND OTHER RESPIRATORY CONDITIONS`
`Emergency/First Aid Procedures`	`EYE CONTACT: WASH IMMEDIATELY WITH PLENTY OF WATER. DILUTE ETHANOL SOLN CAN BE USED TO REMOVE ROSIN. SKIN CONTACT: WASH WITH SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING. GET MEDICAL ATTENTION`

`Steps if Material Released/Spilled`	`REMOVE SOURCES OF IGNITION. WIPE UP IMMEDIATELY BY SOAKING UP INTO ABSORBENT MATERIAL, CLEAN UP WITH ALKALINE DETERGENT`
`Neutralizing Agent`	`NR`
`Waste Disposal Method`	`ACCORDING TO LOCAL REGULATIONS, USUALLY BY INCINERATION`
`Handling and Storage Precautions`	`STORE AWAY FROM SOURCES OF IGNITION. STORE AT TEMPS BELOW 40F MAY RESULT IN PRECIPITATION OF SOME ROSIN. OPEN CONTAINERS CAUTIOUSLY TO ALLOW VENTING OF ANY INTERNAL PRESSURE`
`Other Precautions`	`EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE. OBSERVE ALL LABEL PRECAUTIONS`

`Respiratory Protection`	`USUALLY NOT REQUIRED`
`Ventilation`	`LOCAL EXHAUST; REMOVE SMOKE FROM BREATHING AREA`
`Protective Gloves`	`PLASTIC OR RUBBER GLOVES`
`Eye Protection`	`SAFETY GLASSES OR GOGGLES`
`Other Protective Equipment`	`IMPERVOIUS APRON`
`Work Hygenic Practices`	`WASH HANDS BEFORE EATING OR SMOKING`
`Supplemental Health/Safety Data`	`NR`
`Disposal Code`	`O`

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`YES`
`Contact Code`	`SLIGHT`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	`TARGET ORGANS: SKIN,RESPIRATORY SYSTEM`

`Container Quantity`	`1`
`Unit of Measure`	`QT`

`Volatile Organic Compounds (P/G)`	`4.3558`
`Volatile Organic Compounds (G/L)`	`522`