FLUX, SOLDERING

Material Safety Data Sheet

MSDS Preparer's Information

Alternate Vendors

Vendor #5 CAGE

BJFNN

`Specification Number`	`MIL-STD-130`
`Specification Type/Grade/Class`	`TY I`
`Hazard Storage Compatibility Code`	`C3-L1`
`Appearance/Odor`	`TAN/GOLD COLOR PASTE, NO APPRECIABLE ODOR`
`Boiling Point`	`N/K`
`Melting Point`	`N/K`
`Vapor Pressure`	`N/K`
`Vapor Density`	`N/K`
`Specific Gravity`	`N/K`
`Decomposition Temperature`	`UNKNOWN`
`Evaporation Rate`	`N/K`
`Solubility in Water`	`UNKNOWN`
`Percent Volatiles by Volume`	`N/K`
`Chemical pH`	`N/K`
`Corrosion Rate`	`UNKNOWN`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`S`

`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`N/K`
`Upper Explosion Limit`	`N/K`
`Extinguishing Media`	`USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY CHEMICAL`
`Special Fire Fighting Procedures`	`FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA & FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE`
`Unusual Fire/Explosion Hazards`	`FIRE OR EXCESSIVE HEAT MAY CAUSE PRODUCTION OF ZINC CHLORIDE AND ZINC OXIDE FUMES`

`Stability`	`YES`
`Stability Conditions to Avoid`	`HIGH TEMPERATURES, FLAMES`
`Materials to Avoid`	`CYANIDES`
`Hazardous Decomposition Products`	`ZINC CHLORIDE AND ZINC OXIDE FUMES`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`NOT APPLICABLE`
`LD50 - LD50 Mixture`	`LD50 (ORAL RAT) IS UNKNOWN`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`NO`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`ACUTE-EYES:IRRITATION.SKIN:IRRITATION.INHALATION:IRRITATES RESPIRATORY SYSTEM.CHRONIC-NONE SPECIFIED BY MANUFACTURER`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`NONE OF THE COMPOUNDS IN THIS PRODUCT IS LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN`
`Symptoms of Overexposure`	`EYE, SKIN & RESPIRATORY TRACT IRRITATION`
`Medical Cond. Aggrevated by Exposure`	`PERSONS WITH A HISTORY OF AILMENTS OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE`
`Emergency/First Aid Procedures`	`INHALATION:REMOVE TO FRESH AIR.EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:FLUSH WITH WATER.INGESTION:GIVE PLENTY OF WATER OR MILK.DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION`

`Steps if Material Released/Spilled`	`CONTAIN SPILL, ABSORB, SWEEP-UP, DISPOSE, FLUSH AREA WITH WATER TO CHEMICAL SEWER`
`Neutralizing Agent`	`NOT APPLICABLE`
`Waste Disposal Method`	`DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS`
`Handling and Storage Precautions`	`RE IN A COOL, DRY, WELL VENTILATED AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM PHYSICAL DAMAGE. RE`
`Other Precautions`	`READ THE LABEL ON THE PRODUCT.READ OSHA PUBLICATION 2206 (29CFR1910)`

`Respiratory Protection`	`USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED RESPIRATOR WHEN BRAZING IN CONFINED SPACE OR WHERE LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV`
`Ventilation`	`MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE. LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED`
`Protective Gloves`	`WELDERS GLOVES AND PROTECTIVE FACE SHIED`
`Eye Protection`	`SAFETY GOGGLES WITH OPTIONAL FACE SHIELD`
`Other Protective Equipment`	`EYE WASH STATION AND SAFETY SHOWER. INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED`
`Work Hygenic Practices`	`OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR FOOTWEAR`
`Supplemental Health/Safety Data`	`AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO NOT BREATHE VAPORS OR MISTS.PROVIDE PROTECTION SCREENS AND FLASH GOGGLES.IT IS A MILD ACID AND FLAMMABLE (PER MFR)`

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`NO`
`Contact Code`	`SLIGHT`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	ACUTE-EYES:IRRITATION.SKIN:IRRITATION.INHALATION:IRRITATES RESPIRATORY SYSTEM.CHRONIC-NONE SPECIFIED BY MANUFACTURER.STORAGE-STORE IN A COOL, DRY, WELL VENTILATED AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM PHYSICAL DAMAGE. FIRST AID- INHALATION:REMOVE TO FRESH AIR.EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:FLUSH WITH WATER.INGESTION:GIVE PLENTY OF WATER OR MILK.DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION

`Container Quantity`	`.25`
`Unit of Measure`	`LB`

`Volatile Organic Compounds (P/G)`	`0`
`Volatile Organic Compounds (G/L)`	`0`

`Ingredient #`	`01`
`Ingredient Name`	`(ZNCPD) ZINC CHLORIDE (SARA III)`
`CAS Number`	`7646857`
`NIOSH Number`	`ZH1400000`
`Proprietary`	`NO`
`Percent`	`<40`
`OSHA PEL`	`1 MG/M3/2 STEL`
`ACGIH TLV`	`1 MG/M3/2STEL FUME93`
`Recommended Limit`	`NONE SPECIFIED`
`Ingredient #`	`02`
`Ingredient Name`	`MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')`
`CAS Number`	`8012951`
`NIOSH Number`	`PY8030000`
`Proprietary`	`NO`
`Percent`	`UNKNOWN`
`OSHA PEL`	`5 MG/M3`
`ACGIH TLV`	`5 MG/M3/10 STEL;9192`
`Recommended Limit`	`NONE SPECIFIED`
`Ingredient #`	`03`
`Ingredient Name`	`THE MANUFACTURER STATES THAT REMAINING INGREDIENTS ARE PROPRIETARY AND CLAIMED AS TRADE SECRETS`
`CAS Number`	`UNKNOWN`
`NIOSH Number`	`9999999ZZ`
`Proprietary`	`NO`
`OSHA PEL`	`NOT APPLICABLE`
`ACGIH TLV`	`NOT APPLICABLE`
`Recommended Limit`	`NONE SPECIFIED`