JT6900-5, HYDROCHLORIC ACID

Material Safety Data Sheet

SECTION I - Material Identity
SECTION II - Manufacturer's Information
SECTION III - Physical/Chemical Characteristics
SECTION IV - Fire and Explosion Hazard Data
SECTION V - Reactivity Data
SECTION VI - Health Hazard Data
SECTION VII - Precautions for Safe Handling and Use
SECTION VIII - Control Measures
SECTION IX - Label Data
SECTION X - Transportation Data
SECTION XI - Site Specific/Reporting Information
SECTION XII - Ingredients/Identity Information

SECTION I - Material Identity

`Item Name`
`Part Number/Trade Name`	`JT6900-5, HYDROCHLORIC ACID`
`National Stock Number`	`6810P690005`
`CAGE Code`	`70829`
`Part Number Indicator`	`A`
`MSDS Number`	`148259`
`HAZ Code`	`B`

SECTION II - Manufacturer's Information

`Manufacturer Name`	`J T BAKER INC`
`Street`	`222 RED SCHOOL LANE`
`City`	`PHILLIPSBURG`
`State`	`NJ`
`Country`	`US`
`Zip Code`	`08865-2219`
`Emergency Phone`	`908-859-2151;800-424-9300(CHEMTREC)`
`Information Phone`	`800-582-2537`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`01MAY89`
`Date of Technical Review`	`17APR92`
`Active Indicator`	`N`

Alternate Vendors

Vendor #5 CAGE

BPDPL

SECTION III - Physical/Chemical Characteristics

`Hazard Storage Compatibility Code`	`N/-K`
`Appearance/Odor`	`CLEAR, COLORLESS FUMING LIQUID; PUNGENT ODOR`
`Boiling Point`	`230F,110C`
`Melting Point`	`-13F,-25C`
`Vapor Pressure`	`N/A`
`Vapor Density`	`1.3`
`Specific Gravity`	`1.19 (H*2O=1)`
`Decomposition Temperature`	`N/K`
`Evaporation Rate`	`NOT APPLICABLE`
`Solubility in Water`	`COMPLETE (100%)`
`Percent Volatiles by Volume`	`100`
`Chemical pH`	`SUPDAT`
`Corrosion Rate`	`N/K`
`Container Pressure Code`	`4`
`Temperature Code`	`8`
`Product State Code`	`U`

SECTION IV - Fire and Explosion Hazard Data

`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`N/A`
`Upper Explosion Limit`	`N/A`
`Extinguishing Media`	`USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING FIRE`
`Special Fire Fighting Procedures`	`WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP N). MOVE CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK. USE H*2O TO KEEP FIRE-EXPOS CNTNRS COOL. (SUPDAT)`
`Unusual Fire/Explosion Hazards`	`MAY EMIT HYDROGEN GAS UPON CONTACT WITH METAL. TOXIC GASES PRODUCED:HYDROGEN CHLORIDE, HYDROGEN`

SECTION V - Reactivity Data

`Stability`	`YES`
`Stability Conditions to Avoid`	`HEAT, MOISTURE`
`Materials to Avoid`	`MOST COMMON METALS, WATER, AMINES, METAL OXIDES, ACETIC ANHYDRIDE, PROPIOLACTONE, VINYL ACETATE, MERCURIC (SUPP DATA)`
`Hazardous Decomposition Products`	`HYDROGEN CHLORIDE, HYDROGEN, CHLORINE`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`NOT RELEVANT`
`LD50 - LD50 Mixture`	`LC50:(INHAL,RAT)3124 PPM`

SECTION VI - Health Hazard Data

`Route of Entry: Skin`	`NO`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`ACUTE:INHAL:PULMONARY EDEMA, CIRCULATORY FAILURE, RESPIRATORY SYSTEM (LUNGS) DMG, COLLAPSE, COUGHING, DIFFICULT BRTHG. MAY BE FATAL IF INHALED .SKIN/EYES:CAUSES SEVERE BURNS. CAUSES DMG & IS IRRITATING TO EYES & SKIN. INGEST:IS HARMFUL & MAY BE FATAL, SEVERE BURNS TO MOUTH, THROAT & STOM, NAUS, VOMIT. (EFTS OF OVEREXP)`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`NOT RELEVANT`
`Symptoms of Overexposure`	`HLTH HAZ:TARGET ORGANS:RESPIRATORY SYSTEM, EYES, SKIN. CHRONIC:NONE IDENTIFIED`
`Medical Cond. Aggrevated by Exposure`	`NONE IDENTIFIED`
`Emergency/First Aid Procedures`	`INGEST:CALL MD. DO NOT INDUCE VOMIT. IF CONSCIOUS, GIVE WATER, MILK OR MILK OF MAGNESIA. INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE O*2. SKIN:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS WHILE REMOVING CONTAM CLTHG & SHOES. WASH CLTHG BEFORE RE-USE. EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES`

SECTION VII - Precautions for Safe Handling and Use

`Steps if Material Released/Spilled`	`WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG. STOP LEAK IF YOU CAN DO SO W/OUT RISK. VENT AREA. NEUT SPILL W/SODA ASH/LIME. WITH CLEAN SHOVEL, CAREFULLY PLACE MATL INTO CLEAN, DRY CNTNR & COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER`
`Neutralizing Agent`	`J.T.BAKER NEUTRASORB(R) OR TEAM 'LOW NA+' ACID NEUTRALIZERS ARE RECOM (SUPDAT)`
`Waste Disposal Method`	`DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE NUMBER:D002 (CORROSIVE WASTE)`
`Handling and Storage Precautions`	`P CNTNR TIGHTLY CLSD. LOOSEN CLOSURE CAUTIOUSLY. STORE IN CORROSION-PROOF AREA. ISOLATE FROM INCOMPAT MATLS. DO NOT STORE NEAR OXIDIZING MATLS. CO`
`Other Precautions`	`CORROSIVE. POISON DANGER. DO NOT GET IN EYES, ON SKIN, ON CLTHG. DO NOT BREATHE VAPOR. USE W/ADEQUATE VENTILATION. KEEP OUT OF REACH OF CHILDREN`

SECTION VIII - Control Measures

`Respiratory Protection`	`RESPIRATORY PROTECTION REQD IF AIRBORNE CONC EXCEEDS TLV. AT CONCS UP TO 100 PPM, A NIOSH/MSHA APPRVD CHEM CARTRIDGE RESPIRATOR W/ACID CARTRIDGE IS RECOM. ABOVE THIS LEVEL, A NIOSH/MSHA APPRVD SCBA IS ADVISED`
`Ventilation`	`USE GENERAL/LOCAL EXHAUST VENTILATION TO MEET TLV REQUIREMENTS. VENT HOOD`
`Protective Gloves`	`NEOPRENE GLOVES`
`Eye Protection`	`CHEM WORK GOGG & FULL LGTH FCSHLD(FP N)`
`Other Protective Equipment`	`UNIFORM, PROTECTIVE SUIT, LAB COAT & APRON. EMERGENCY EYE WASH & DELUGE SHOWER (FP N)`
`Work Hygenic Practices`	`WASH THOROUGHLY AFTER HANDLING`
`Supplemental Health/Safety Data`	`PH:1 (O.1M SOLUTION). FIRE FIGHT PROC:DO NOT GET WATER INSIDE CONTAINERS. MATLS TO AVOID:SULFATE, CALCIUM PHOSPHIDE, FORMALDEHYDE, ALKALIES, CARBONATES, STRONG BASES, SULFURIC ACID, CHLOROSULFONIC ACID. NEUT AGENT:FOR SPILLS OF THIS PRODUCT`
`Disposal Code`	`O`

SECTION IX - Label Data

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`UNKNOWN`
`Contact Code`	`SEVERE`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`

SECTION X - Transportation Data

`Container Quantity`	`500`
`Unit of Measure`	`ML`

SECTION XI - Site Specific/Reporting Information

`Volatile Organic Compounds (P/G)`	`0`
`Volatile Organic Compounds (G/L)`	`0`

SECTION XII - Ingredients/Identity Information

`Ingredient #`	`01`
`Ingredient Name`	`HYDROCHLORIC ACID`
`CAS Number`	`7647010`
`NIOSH Number`	`MW4025000`
`Proprietary`	`NO`
`Percent`	`33-40`
`OSHA PEL`	`5 PPM, C`
`ACGIH TLV`	`5 PPM, C`
`Recommended Limit`	`N/K`
`Ingredient #`	`02`
`Ingredient Name`	`WATER`
`CAS Number`	`7732185`
`NIOSH Number`	`ZC0110000`
`Proprietary`	`NO`
`Percent`	`60-67`
`OSHA PEL`	`NOT APPLICABLE`
`ACGIH TLV`	`NOT APPLICABLE`
`Recommended Limit`	`N/K`