DEVGUARD 4308 ALKYD IND. GLOSS ENAMEL/BLUE/1793

Material Safety Data Sheet

SECTION I - Material Identity
SECTION II - Manufacturer's Information
SECTION III - Physical/Chemical Characteristics
SECTION IV - Fire and Explosion Hazard Data
SECTION V - Reactivity Data
SECTION VI - Health Hazard Data
SECTION VII - Precautions for Safe Handling and Use
SECTION VIII - Control Measures
SECTION IX - Label Data
SECTION X - Transportation Data
SECTION XI - Site Specific/Reporting Information
SECTION XII - Ingredients/Identity Information

SECTION I - Material Identity

`Item Name`
`Part Number/Trade Name`	`DEVGUARD 4308 ALKYD IND. GLOSS ENAMEL/BLUE/1793`
`National Stock Number`	`8010P4308`
`CAGE Code`	`ICIPT`
`Part Number Indicator`	`A`
`MSDS Number`	`194754`
`HAZ Code`	`C`

SECTION II - Manufacturer's Information

`Manufacturer Name`	`ICI PAINTS/DEVOR COATINGS`
`Street`	`925 EUCLID AVE`
`City`	`CLEVELAND`
`State`	`OH`
`Country`	`US`
`Zip Code`	`44115`
`Emergency Phone`	`800-545-2643`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`06AUG02`
`Active Indicator`	`Y`

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Appearance/Odor`	`BLUE PAINT`
`Boiling Point`	`277-415`
`Melting Point`	`N/A`
`Vapor Pressure`	`N/A`
`Vapor Density`	`N/A`
`Specific Gravity`	`1`
`Evaporation Rate`	`N/A`
`Solubility in Water`	`N/A`
`Percent Volatiles by Volume`	`50.72`
`Chemical pH`	`N/A`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

SECTION IV - Fire and Explosion Hazard Data

`Flash Point`	`105`
`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`NA`
`Upper Explosion Limit`	`NA`
`Extinguishing Media`	`DRY CHEMICAL, FOAM WATER FOG, CARBON DIOXIDE`
`Special Fire Fighting Procedures`	`WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS. FIREFIGHTERS SHOULD USE FULLL PROTECTIVE CLOTHING, EYE PROTECTION & SCBA`
`Unusual Fire/Explosion Hazards`	`CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT AMBIENT TEMP. VAPORS HEAVIER THAN AIR & MAY TRAVEL LONG DISTANCES`

SECTION V - Reactivity Data

`Stability`	`YES`
`Stability Conditions to Avoid`	`ELEVATED TEMPS. CONTACT W/OXIDIZING AGENTS, SPARKS, OPEN FLAME, IGNITION SOUCES`
`Materials to Avoid`	`OXIDIZERS, ACIDS, BASES, AMINES, PEROXIDES, NITRIC ACIDS`
`Hazardous Decomposition Products`	`CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN, ACID FUMES, PHOSPHOROUS, AMMONIA, TOXIC GASES, OXIDED OF CALCIUM`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`

SECTION VI - Health Hazard Data

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`CHRONIC: REPEATED OR PROLONGED EXPOSURE MAY CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE, TOXICITY TO LIVER, KIDNEY, CENTRAL NERVOUS SYSTEM. INTENTIONAL MISUES BY DILBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL`
`Carcinogenity: NTP`	`YES`
`Carcinogenity: IARC`	`YES`
`Carcinogenity: OSHA`	`YES`
`Explanation of Carcinogenity`	`CONTAINS CRYSTALLINE SILICA, A KNOWN CARCINOGEN`
`Symptoms of Overexposure`	[INHALE] IRRITATION OF RESPIRATORY TRACT, MUCOUS MEMBRANE IRRITATION, FATIGUE, DIZZINESS, HEADACHE, UNCOORDINATION, NAUSEA, VOMITING, BLURRED VISION, DIFFICULTY W/SPEECH, CNS DEPRESSION, NARCOSIS, DIFFICULT BREATHING, ALLERGIC RESPONSE, TREMRS, UNCONSCIOUSNESS, ASPHYXIATION, DEATH. [SKIN] IRRITATION, DERMATITIS (CONTD SIGNS) EYE:SEVERE IRRITATION, CONJUCTIVITIS, BLURRED VISION, TEARING, REDNESS INGEST: LUNG INFLAMMATION, GASTRO-INTESTINAL DISTURBANCES, PULMONARY EDEMA, KIDNEY DAMAGE, SAME AS INHALE SYMPTOM
`Medical Cond. Aggrevated by Exposure`	`EYE, SKIN, RESPIRATORY DISORDERS`
`Emergency/First Aid Procedures`	[EYE] FLUSH W/WATER FOR AT LEAST 15 MIN. LIFTING EYELIDS, IF IRRITATION PERSISTS OR OCCURS, SEEK MED. ATTN. [SKIN] FLUSH W/WATER, WASH WITH MILD SOAP, IF ANY PRODUCT REMAINS, GENTLY RUB PETROLEUM JELLY, ETC. ONTO SKIN. REMOVE CONTAMINATED CLOTHING, LAUNDER BEFORE REUSE. IF IRRITATION PERSISTS OR OCCURS, SEEK MED. ATTN. [INHALE] MOVE TO FRESH AIR, IF NECESSARY GIVE ARTIFICIAL RESPIRATION OR OXYGEN. GET MED. ATTN. [INGEST] GET IMMED. MED. ATTN. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON

SECTION VII - Precautions for Safe Handling and Use

`Steps if Material Released/Spilled`	`ELIMINATE ALL SOURCES OF IGNITION, VENTILATE AREA, COLLECT W/ABSORBENT MATERIALS. EVACUATE ALL UNNECESSARY PERSONNEL. PLACE COLLECTED MATERIAL IN PROPER CONTAINER. FOR LG. SPILLS DIKE AND CONTAIN, PUMP TO STORAGE OR SALVAGE VESSELS`
`Neutralizing Agent`	`NONE LISTED`
`Waste Disposal Method`	`IN ACCORDANCE W/STATE, LOCAL, AND FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS`
`Handling and Storage Precautions`	`STROE BELOW 100F KEEP AWAY FROM ALL SOURCES OF IGNITION. USE ONLY W/ADEQUATE VENTILATION. GROUND EQUIPMENT WHEN TRANSFERRING. KEEP CONTAINERS TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE. EMPTY CONTAINERS MAY CONTAIN HAZ. RESIDUES`
`Other Precautions`	`READ AND UNDERSTAND ALL CAUTIONS, LABELS AND MSDS BEFORE USING ANY CHEMICAL PRODUCT`

SECTION VIII - Control Measures

`Respiratory Protection`	`IF CONCENTRATIONS ARE ABOVE APPLICABLE STANDARDS USE NIOSH/MSHA APPROVED RESPIRATOR`
`Ventilation`	`PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD UP OF VAPORS. USE EXPLOSION PROOF/NON SPARKING EQUIP`
`Protective Gloves`	`IMPERVIOUS GLOVES`
`Eye Protection`	`SAFETY GLASSES/GOGGLES/FACE SHIELD`
`Other Protective Equipment`	`IMPERVIOUS CLOTHING, APRON, BOOTS, EYE WASH, SAFETY SHOWER`
`Work Hygenic Practices`	`WASH HANDS THOROUGHLY AFTER HANDLING`
`Supplemental Health/Safety Data`	`REMOVE CONTAMINATED CLOTHING /LAUNDER BEFORE REUSE. WASH HANDS AFTER EACH USE AND BEFORE EATING, DRINKING, ETC. MINIMIZE CONTACT OF PRODUCT ON SKIN`

SECTION IX - Label Data

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`YES`
`Contact Code`	`UNKNOWN`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	`MAY AGGRAVATE EYE, SKIN, RESPIRATORY DISORDERS`

SECTION X - Transportation Data

SECTION XI - Site Specific/Reporting Information

`Volatile Organic Compounds (P/G)`	`3.315`
`Volatile Organic Compounds (G/L)`	`397.2657`

SECTION XII - Ingredients/Identity Information

`Ingredient #`	`01`
`Ingredient Name`	`BENZENE, ETHYL-`
`CAS Number`	`100414`
`Percent`	`1`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`02`
`Ingredient Name`	`BENZENE, DIMETHYL-`
`CAS Number`	`1330207`
`Percent`	`5`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`03`
`Ingredient Name`	`TITANIUM OXIDE`
`CAS Number`	`13463677`
`Percent`	`20`
`OSHA PEL`	`10 MG/M3`
`ACGIH TLV`	`10 MG/M3`
`Ingredient #`	`04`
`Ingredient Name`	`HEXANOIC ACID, 2-ETHYL-,COBALT(2+)SALT`
`CAS Number`	`136527`
`Percent`	`1`
`OSHA PEL`	`.05 MG/M3`
`ACGIH TLV`	`.02 MG/M3`
`Ingredient #`	`05`
`Ingredient Name`	`NATHTHA (PETROLEUM) HEAVY ALKYLATE`
`CAS Number`	`64741657`
`Percent`	`20`
`OSHA PEL`	`500 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`06`
`Ingredient Name`	`DISTILLATES (PETROLEUM) HYDROTREATED LIGHT`
`CAS Number`	`64742478`
`Percent`	`5`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`07`
`Ingredient Name`	`SOLVENT NAPHTHA, PETROLEUM, MEDIUM ALIPH`
`CAS Number`	`64742887`
`Percent`	`20`
`OSHA PEL`	`500 X PPM`
`Ingredient #`	`08`
`Ingredient Name`	`SOLVENT NAPHTHA, PETROLEUM, LIGHT AROM`
`CAS Number`	`64742956`
`Percent`	`5`
`OSHA PEL`	`500 X PPM`
`Ingredient #`	`09`
`Ingredient Name`	`SOYBEAN OIL. POLYMER W/PENTAERYTHRITOL, TDI AND TUNG OIL`
`CAS Number`	`67989280`
`Percent`	`10`
`Ingredient #`	`10`
`Ingredient Name`	`LECITHINS`
`CAS Number`	`8002435`
`Percent`	`5`
`Ingredient #`	`11`
`Ingredient Name`	`BENZENE, 1,2,4-TRIMETHYL-`
`CAS Number`	`95636`
`Percent`	`1`
`Ingredient #`	`12`
`Ingredient Name`	`LONG OIL ALKYD RESIN`
`CAS Number`	`1002`
`Percent`	`40`
`Ingredient #`	`13`
`Ingredient Name`	`(COLORANT)1,2-ETHANEDIOL`
`CAS Number`	`107211`
`Percent`	`0`
`Ingredient #`	`14`
`Ingredient Name`	`(COLORANT) ETHANOL, 2,2'-IMINOBIS-`
`CAS Number`	`111422`
`Percent`	`0`
`ACGIH TLV`	`2 MG/M3`
`Ingredient #`	`15`
`Ingredient Name`	`(COLORANT) ETHANOL, 2,2'-[1,2-ETHANEDIYLBIS(OXY)]BIS-`
`CAS Number`	`112276`
`Percent`	`0`
`Ingredient #`	`16`
`Ingredient Name`	`(COLORANT) POLY(OXY-1,2-ETHANEDIYL), .ALPHA.-(4-NONYLPHENYL)-.OMEGA.-HYDROXY-,BRANCHED`
`CAS Number`	`127087870`
`Percent`	`0`
`Ingredient #`	`17`
`Ingredient Name`	`(COLORANT) KAOLIN`
`CAS Number`	`1332587`
`Percent`	`0`
`OSHA PEL`	`5 MG/M3`
`ACGIH TLV`	`2 MG/M3`
`Ingredient #`	`18`
`Ingredient Name`	`(COLORANT) 9-OCTADECENCIC ACID, 12-HYDROXY-METHYL ESTER. (R-(Z))`
`CAS Number`	`141242`
`Percent`	`0`
`Ingredient #`	`19`
`Ingredient Name`	`(COLORANT) (CUCPD) COPPER, [29H,31H-PHTHALOCYANINATO(2-)-N29,N30,N31,N32]-, (SP-4-1)-`
`CAS Number`	`147148`
`Percent`	`0`
`OSHA PEL`	`.05 MG/,3`
`ACGIH TLV`	`10 MG/M3`
`Ingredient #`	`20`
`Ingredient Name`	`(COLORANT) WATER`
`CAS Number`	`7732185`
`Percent`	`0`
`Ingredient #`	`21`
`Ingredient Name`	`(COLORANT) 2-PYRROLIDINONE, 1-METHYL-`
`CAS Number`	`872504`
`Percent`	`0`