CATHA-COAT 302H - REINFORCD INORGANIC ZINC PRIMR

Material Safety Data Sheet

`Item Name`
`Part Number/Trade Name`	`CATHA-COAT 302H - REINFORCD INORGANIC ZINC PRIMR - CONVERTER`
`National Stock Number`	`8010P302H0250`
`CAGE Code`	`60785`
`Part Number Indicator`	`B`
`MSDS Number`	`193158`
`HAZ Code`	`B`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`08AUG02`
`Active Indicator`	`Y`

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Flash Point`	`80`
`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`NR`
`Upper Explosion Limit`	`NR`
`Extinguishing Media`	`DRY CHEMICAL OR FOAM, WATER FOG, CO2. CLOSED CONTAINERS MAY BURST IF EXPOSED TO EXTREME HEAT OR FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT AMBIENT TEMPS. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL LONG DISTANCES TO A SOURCE OF IGNITION AND CONDITIONS EMITTING IRRITANT AND OR TOXIC GASES`
`Special Fire Fighting Procedures`	`WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS. FIREFIGHTERS SHOULD USE FULL PROTECTIVE CLOTHING, EYE PROTECTION, AND SELF CONTAINED BREATHING APPARATUS`
`Unusual Fire/Explosion Hazards`	`NR`

`Stability`	`YES`
`Stability Conditions to Avoid`	`ELEVATED TEMPERATURES, MOISTURE, CONTACT WITH OXIDIZING AGENTS. SPARKS, OPEN FLAME, IGNITION SOURCES`
`Materials to Avoid`	`OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALDEHYDES, KETONES, HALOGENS, AMINES, CARBON TETRACHLORIDE (AT ELEVATED TEMPS), ALUMINUM, METAL COMPOUNDS, PHOSPHORUS, LEWIS ACIDS, MINERAL ACIDS`
`Hazardous Decomposition Products`	`CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN,OXIDES OF SULFUR, AMMONIA, ALDEHYDES, TOXIC GASSES, BARIUM COMPOUNDS`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`[INHAL] IRRITATION OF RESPIRATORY TRACT, LUNGS. PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS, DIZZINESS AND OR LIGHTHEADNESS, HEADACHE, NAUSEA, CHEST PAIN, COUGHING, CENTRAL NERVOUS SYSTEM DEPRESSION, DIFFICULTY OF BREATHING, KIDNEY DAMAGE, PNEUMOCONIOSIS. [SKIN] IRRITATION. PROLONGED OR REPEATED CAN CAUSE DERMATITIS, DEFATTING. POSSIBLE SENSITIZATION TO SKIN. [EYE] IRRITATION OF EYES, SEVERE EYE IRRITATION OR BURNS. [INGEST] MOUTH AND THROAT IRRITATION, DIZZINESS`
`Symptoms of Overexposure`	`SEE ABOVE`
`Medical Cond. Aggrevated by Exposure`	`EYE, SKIN, RESPIRATORY DISORDERS ASTHMA-LIKE CONDITIONS KIDNEY DISORDERS`
`Emergency/First Aid Procedures`	[INHAL] REMOVE TO FRESH AIR. RESTORE AND SUPPORT CONTINUED BREATHING. GET EMERGENCY MEDICAL ATTEN. OXYGEN OR ARTIFICAL RESPIRATION AS NEEDED. [SKIN] FLUSH FROM SKIN WITH WATER. THEN WASH THOROUGHLY WITH SOAP AND WATER., REMOVE CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE RE-USE. [EYE] FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY UNDER LIDS FOR AT LEAST 15 MIN. IF IRRITATION OR OTHER EFFECTS PERSIST, OBTAIN MEDICAL TREATMENT. [INGEST] IF SWALLOWED, OBTAIN MEDICAL TREATMENT IMMEDIATELY

`Steps if Material Released/Spilled`	`COMPLY WITH ALL APPLICABLE HEALTH AND ENVIRONMENTAL REGULATIONS. ELIMINATE ALL SOURCES OF IGNITION. VENTILATE AREA. SPILL. SPILLS MAY BE COLLECTED WITH WITH ABSORBENT MATERIAL. PLACE COLLECTED MATERIAL IN PROPER MATERIAL IN PROPER CONTAINER. COMPLETE PERSONAL PROTECTIVE EQUIPMENT MUST BE USED DURING CLEANUP`
`Neutralizing Agent`	`NR`
`Waste Disposal Method`	`DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS`
`Handling and Storage Precautions`	`STORE BELOW 100 F (38C) . KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. USE ONY WITH ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT WITH SKIN AND EYES, AND BREATHING OF VAPORS. WASH HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY BEFORE EATING OR SMOKING`
`Other Precautions`	`KEEP CONTAINERS TIGHTLY CLOSED AND UPRIGHT WHEN NOT IN USE. EMPTY CONTAINERS MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN TRANSFERRING TO PREVENT ACCUMULATION OF STATIC CHARGE`

`Respiratory Protection`	`USE NIOSH/MSHA FACEPIECE RESPIRATOR OUTFITTED W/ORGANIC VAPOR CARTRIDGES & PAINT SPRAY PREFILTERS WHEN ENVIRONMENTAL CONCENTRATIONS ARE >TLV/PEL LEVELS`
`Ventilation`	`DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD UP OF VAPORS. USE EXPLOSION PROOF EQUIP./NON-SPARKING EQUIP`
`Protective Gloves`	`IMPERVIOUS GLOVES`
`Eye Protection`	`SAFETY GLASSES/GOGGLES`
`Other Protective Equipment`	`EYE WASH, SAFETY SHOWER, IMPERVIOUS CLOTHING, BOOTS`
`Work Hygenic Practices`	`THOROUGHLY CLEAN CONTAMINATED CLOTHING BEFORE REUSE. DISCARD LEATHER ARTICLES THAT CAN NOT BE DECONTAMINATED`

`Volatile Organic Compounds (P/G)`	`2.6208`
`Volatile Organic Compounds (G/L)`	`314.0736`

`Ingredient #`	`01`
`Ingredient Name`	`2-HEPTANONE (20-30%)`
`CAS Number`	`110430`
`Proprietary`	`NO`
`Percent`	`30`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`50 PPM`
`Ingredient #`	`02`
`Ingredient Name`	`1,2-ETHANEDIAMINE, N,N'-BIS(2-AMINOETHYL)- (1-5%)`
`CAS Number`	`112243`
`Proprietary`	`NO`
`Percent`	`5`
`Ingredient #`	`03`
`Ingredient Name`	`*FATTY ACIDS, C18-UNSAID, DIMERS, REACTION PRODUCTS WITH POLYETHYIENEPOLYAMINES (40-50%)`
`CAS Number`	`68410231`
`Proprietary`	`NO`
`Percent`	`50`
`OSHA PEL`	`NE`
`ACGIH TLV`	`NE`
`Ingredient #`	`04`
`Ingredient Name`	`1-BUTANOL (10-20%)`
`CAS Number`	`71363`
`Proprietary`	`NO`
`Percent`	`20`
`OSHA PEL`	`NE`
`ACGIH TLV`	`NE`
`Ingredient #`	`05`
`Ingredient Name`	`*AMINE ADDUCT (10-20%)`
`CAS Number`	`1003`
`Proprietary`	`NO`
`Percent`	`20`