POLYURETHANE ACCELERATOR (PART C OF 4)

Material Safety Data Sheet

`Item Name`
`Part Number/Trade Name`	`CAAPCOAT POLYURETHANE ACCELERATOR (PART C OF 4)`
`National Stock Number`	`8010PB-274`
`CAGE Code`	`60922`
`Part Number Indicator`	`C`
`MSDS Number`	`191966`
`HAZ Code`	`C`

MSDS Preparer's Information

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Specification Number`	`MIL-C-83231`
`Specification Type/Grade/Class`	`TYPE II CLASS A`
`Hazard Storage Compatibility Code`	`F6`
`NRC License Number`	`NR`
`Net Propellant Weight (Ammo)`	`NR`
`Appearance/Odor`	`CLEAR LIQUID WITH KETONE ODOR`
`Boiling Point`	`175F-241F`
`Melting Point`	`NR`
`Vapor Pressure`	`48`
`Vapor Density`	`2.9`
`Specific Gravity`	`0.80`
`Decomposition Temperature`	`NR`
`Evaporation Rate`	`3.0 (BUTYL ACETATE=1)`
`Solubility in Water`	`SLIGHT`
`Percent Volatiles by Volume`	`NR`
`Chemical pH`	`NR`
`Corrosion Rate`	`NR`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

`Flash Point`	`23`
`Flash Point Method`	`TCC`
`Lower Explosion Limit`	`1`
`Upper Explosion Limit`	`11.5`
`Extinguishing Media`	`USE WATER FOG, DRY CHEMICAL, FOAM, CARBON DIOXIDE. DO NOT USE DIRECT WATER STREAM`
`Special Fire Fighting Procedures`	`FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL NEARBY CONTAINERS AND STRUCTURES EXPOSED TO FIRE`
`Unusual Fire/Explosion Hazards`	`FLAMMABLE LIQUID. AVOID ACCUMULATION OF WATER AS THIS PRODUCT MAY FLOAT ON WATER AND MAY REIGNITE ON THE SURFACE OF THE WATER. EXTINGUISH ALL NEARBY SOURCES OF IGNITION BECAUSE THE VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL A CONSIDERABLE DISTANCE TO AN IGNITION SOURCE AND FLASHBACK`

`Stability`	`YES`
`Stability Conditions to Avoid`	`KEEP AWAY FROM ALL IGNITION SOURCES, HOT SURFACES, AND TEMPERATURES ABOVE 100 F. DO NOT SMOKE IN THE IMMEDIATE AREA`
`Materials to Avoid`	`STRONG OXIDIZING AGENTS, CHLORINATED COMPOUNDS, COPPER ALLOYS, AND ALKALIS`
`Hazardous Decomposition Products`	`CARBON MONOXIDE, CARBON DIOXIDE, UNIDENTIFIED ORGANIC COMPOUNDS MAY BE RELEASED DURING COMBUSTION`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`[ACUTE] CONTACT MAY DAMAGE EYES, IRRITATE SKIN, AND CAUSE RESPIRATORY IRRITATION UPON INHALATION. [CHRONIC] VAPORS/MISTS IRRITATE THE NOSE AND THROAT. INHALATION OF HIGHER CONCENTRATIONS MAY CAUSE KIDNEY/LIVER DAMAGE`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`NONE`
`Symptoms of Overexposure`	`VAPOR EXPOSURE: BURNING EYES, HEADACHE, DIZZINESS, THROAT IRRITATION, LOSS OF APPETITE, NAUSEA, VOMITING. CONTACT: MAY CAUSE IRRITATION OF SKIN OR EYES`
`Medical Cond. Aggrevated by Exposure`	`PREEXISTING ALLERGIES, EYE, SKIN AND RESPIRATORY DISORDERS`
`Emergency/First Aid Procedures`	[EYES] FLUSH W/WATER 15 MIN, LIFTING LIDS OCCASIONALLY. GET IMMED MED ATTEN. [SKIN] WASH WELL W/SOAP/WATER. REMOVE CONTAMINATED CLOTHING. WASH BEFORE REUSE. IF IRRITATION/SIGNS OF OVEREXPOSURE PERSIST IMMED MED ATTEN. [INHALE] REMOVE TO FRESH AIR. ARTIFICIAL IF NEEDED. IMMED MED ATTEN. [INGEST] IMMED MED ATTEN. NO VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP VICTIMS HEAD BELOW HIPS TO PREVENT BREATHING VOMITUS INTO LUNGS. A SMALL QUANTITY OF THE PRODUCT IN THE LUNGS CAN RESULT IN SERIOUS LUNG DAMAGE

`Steps if Material Released/Spilled`	`REMOVE ALL SOURCES OF IGNITION AND DO NOT SMOKE IN THE AREA. WEAR PROTECTIVE EQUIPMENT INCLUDING RUBBER BOOTS, RUBBER GLOVES, RUBBER APRON, AND SCBA IN PRESSURE DEMAND MODE OR AN AIR SUPPLIED RESPIRATOR. ALWAYS WEAR EYE PROTECTION. CONTAIN THE SPILL WITH ABSORBENT MATERIAL. CLEAN UP THE ABSORBENT AND CONTAIN SECURELY. SWEEP AND WET MOP THE AFFECTED AREA WITH SOAP AND WATER. VENTILATE THE AREA AS WELL AS POSSIBLE`
`Neutralizing Agent`	`NR`
`Waste Disposal Method`	`INCINERATION IN APPROPRIATELY DESIGNED/LICENSED INCINERATOR. THIS IS A RCRA HAZARDOUS IGNITABLE WASTE. REGULATIONS MAY VARY STATE-STATE. DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS`
`Handling and Storage Precautions`	`NR`
`Other Precautions`	`NR`

`Respiratory Protection`	`FOR VAPORS/MISTS USE NIOSH APPROVED RSPRTR APPROP FOR EMISSION LEVELS AT POINT OF USE. APPROP RSPRTR W/FULL FACEPIECE/PURIFYING CARTRIDGE RSPRTR EQUIPPED FOR ORGANIC VAPORS/MISTS/SCBA IN PRESSURE DEMAND MODE/SUPPLIED AIR RSPRTR`
`Ventilation`	`PRODUCT NOT USED ALONE, USED IN CONJUNCTION W/CAAPCOAT POLYURETHANE COATINGS. SPRAY BOOTH FOR SPRAY APPLICATIONS.**`
`Protective Gloves`	`SOLVENT RESISTANT GLOVES`
`Eye Protection`	`SOLVENT RESISTANT SAFETY GLASSES`
`Other Protective Equipment`	`SOLVENT RESISTANT APRON. NO CONTACT LENSES. EYEWASH/SAFETY SHOWER NEARBY`
`Work Hygenic Practices`	`WASH WELL WITH SOAP AND WATER AFTER HANDLING THE PRODUCT`

`Container Quantity`	`8`
`Unit of Measure`	`OZF`

`Volatile Organic Compounds (P/G)`	`6.67`
`Volatile Organic Compounds (G/L)`	`799.325`