| Stability |
YES |
| Stability Conditions to Avoid |
EXCESSIVE HEAT |
| Materials to Avoid |
UNCONTROLLED EXPOS TO STRONG OXIDIZING AGENTS,ACIDS,HALOGENATED ORGANIC CMPDS,ALDEHYDES,KETONES,ANHYDRIDES,& (SEE SUPP) |
| Hazardous Decomposition Products |
NITROGEN OXIDES,CARBON DIOXIDE,CARBON MONOXIDE,ALDEHYDES AND OTHER HAZARDOUS ORGANICS |
| Hazardous Polymerization |
YES |
| Polymerization Conditions to Avoid |
POLYM DOES NOT NORMALLY OCCUR.MAY OCCUR WHEN MIXED W/ EPOXY RESIN AT ELEVATED TEMP (>150F,66C),ESP IF QTIES >1 POUND |
| LD50 - LD50 Mixture |
N/K |
| Route of Entry: Skin |
NO |
| Route of Entry: Ingestion |
YES |
| Route of Entry: Inhalation |
YES |
| Health Hazards - Acute and Chronic |
HARMFUL IF SWALLOWED.SENSITIZER.CAN CAUSE ALLERGIC SKIN REACTION WHICH MAY BE SEVERE IN CERTAIN INDIVIDUALS.LONG TERM EFFECTS HAVE NOT BEEN FULLY DEFINED ALTHOUGH LONG-TERM CONTACT MAY CAUSE SENSITIZATION |
| Carcinogenity: NTP |
NO |
| Carcinogenity: IARC |
NO |
| Carcinogenity: OSHA |
NO |
| Explanation of Carcinogenity |
NONE |
| Symptoms of Overexposure |
EYES:MAY CAUSE SEVERE INJURY.VAPORS MAY CAUSE MINOR INJURY WHICH MAY PERSIST FOR SEVERAL DAYS.SKIN:MAY CAUSE SEVERE INJURY,REDDENING,SWELLING.INGEST:HARMFUL IF SWALLOWED.INHALATION:COULD CAUSE HEADACHE,NAUSEA,DIZZINESS AND RESPIRATORY IRRITATION IF INHALED |
| Medical Cond. Aggrevated by Exposure |
ASSORTED SKIN AND EYE CONDITIONS SUCH AS ECZEMA,PSORIASIS AND DERMATITIS |
| Emergency/First Aid Procedures |
EYES:IMMED FLUSH W/ LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.CONTACT MD IMMED.SKIN:IMMED WASH THOROUGHLY WITH SOAP & WATER.IF IRRIT PERSISTS CONTACT MD IMMED.INGEST:CALL MD OR POISON CONTROL CENTER IMMED.GIVE 1-2 GLASSES OF WATER.DO NOT GIVE ANYTHING BY MOUTH TO AN UNCON PERSON.INHAL:MOVE TO FRESH AIR IF SYMPTOMS OCCUR.IF BRTHG STOPS,GIVE ARTIFICIAL RESP.KEEP WARM & AT REST.SEEK MED ATTN |
| Steps if Material Released/Spilled |
OBSERVE ALL PRECAUTIONS.ELIMINATE ALL IGNITION SOURCES.WEAR SCBA (FP A) & OTHER PROT EQUIP.COLLECT SPILL & CLEAN UP RESIDUE W/ INERT,ABSORBENT MATL (SAND,VERMICULITE,ETC).PLACE IN US DEPT OF TRANSPORTATION APPRVD METAL CONTR & SEAL |
| Neutralizing Agent |
N/K |
| Waste Disposal Method |
DISP MUST BE IAW FED,STATE,& LOC REGS.COORDINATION W/ SUPPORTING INSTALLATION/MACOM ENVIRON COORDINATION PRIOR TO DISP IS REC TO DETERM APPROP DISP METH (FP A).INCIN OR LANDFILL.DO NOT CONTAMINATE LAKES,STREAMS,PONDS OR UNDERGROUND WATER SUPPLY |
| Handling and Storage Precautions |
RE AT 80F,27C OR BELOW.AVOID EYE/SKIN CONT.DO NOT ALLOW CONTACT W/ CU,CU ALLOY,AL OR AL ALLOY MATERIAL.BULK STORAGE UNDER NITROGEN OR ARGON BLANKET CO |
| Other Precautions |
CONTAINS MINERAL FILLERS IN WETTED,NON-AIRBORNE FORM.SOME COMPONENTS CLASSIFIED HAZ IN AIR-BORNE FORM.DO NOT INHALE DUST OF CURED MATL MACHINED/CUT/SANDED/HANDLED IN WAY TO RELEASE PARTICLES INTO AIR;USE NIOSH APPROVED PARTICULATE RESP |
| Respiratory Protection |
NIOSH ORGANIC FUME RESP RECOMENDED IN POORLY VENTILATED AREAS OR WHEN MATL IS AT ELEVATED TEMP.SCBA REC FOR LRG QTIES IN POORLY VENT AREAS OR AREAS OF HIGH VAPOR CONCENTRATION |
| Ventilation |
MECH VENTILATION ACCEPT W/ SMALL AMT AT ROOM TEMP.GOOD LOCAL VENT RECOM IN POORLY VENT AREA OR WHEN MATL IS AT (SEE SUPP |
| Protective Gloves |
IMPERVIOUS LATEX OR RUBBER GLOVES |
| Eye Protection |
FACE SHIELD W/ CHEM GOGGLES MANDTRY(FP A |
| Other Protective Equipment |
WHERE SKIN CONTACT CAN OCCUR,WEAR COVERALLS,APRON & RUBBER FOOT COVERINGS.SAFETY SHOWER & EYE WASH SHOULD BE AVAILABLE |
| Work Hygenic Practices |
WASH CONTAM CLTHG BEFORE REUSE.DISCARD SEV CONTAM CLTHG.GOOD PERSONAL HYGIENE,MINIMAL SKIN/VAP CONTACT ESP IF HEATED |
| Supplemental Health/Safety Data |
DO NOT WEAR CONTACT LENSES DURING/IN AREA OF USE.MATLS TO AVOID:ACRYLATES.MIXTURES W/ THESE MATLS WILL RESULT IN TEMPERATURE OR PRESSURE INCREASE. VENTILATION:ELEVATED TEMPERATURE.VENT CURING OVENS OUTDOORS |
| Disposal Code |
O |
