ADHESIVE LCA-49

Material Safety Data Sheet

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`06APR93`
`Active Indicator`	`N`

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Specification Number`	`N/R`
`Appearance/Odor`	`LIGHT TAN LIQUID PASTE; SLIGHT ETHER ODOR`
`Boiling Point`	`500 F`
`Vapor Pressure`	`NIL`
`Vapor Density`	`1`
`Specific Gravity`	`1.78`
`Solubility in Water`	`NIL`
`Container Pressure Code`	`4`
`Temperature Code`	`8`
`Product State Code`	`U`

`Flash Point Method`	`PMCC`
`Extinguishing Media`	`WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL`
`Special Fire Fighting Procedures`	`WEAR POSITIVE SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING. AVOID BREATHING SMOKE`
`Unusual Fire/Explosion Hazards`	`KEEP NONIGNITED MATERIAL COOL WATER SPRAY. POSSIBLE EXOTHERMIC REACTION IF THE MATERIAL IS HEATED >400F IN A CONTAINER CONTAINING GREATER THAN 1 GALLON OF MATER`

`Stability`	`YES`
`Stability Conditions to Avoid`	`LARGE MASSES MAY EXOTHERM WHEN CURED`
`Materials to Avoid`	`UNCONTROLLED EXPOSURE TO STRONG ACIDS, AMINES,MERCAPTANS, BASES & STRONG OXIDIZING AGENTS`
`Hazardous Decomposition Products`	`NITROGEN OXIDES, CARBON DIOXIDE, CARBON MONOXIDE, ALDEHYDES, AND OTHER HAZARDOUS ORGANICS`
`Polymerization Conditions to Avoid`	`WILL NOT ORDINARIYL OCCUR`
`LD50 - LD50 Mixture`	`N/R`

`Route of Entry: Skin`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`N/R`
`Carcinogenity: NTP`	`N/R`
`Carcinogenity: IARC`	`N/R`
`Carcinogenity: OSHA`	`N/R`
`Symptoms of Overexposure`	`MAY CAUSE SKIN OR EYE IRRITATION/SENSITIZATION AFTER REPEATED CONTACT OR INHALATION OF VAPOR MAY CAUSE SENSITIZATION`
`Medical Cond. Aggrevated by Exposure`	`N/R`
`Emergency/First Aid Procedures`	`EYE: FLUSH WITH WATER FOR 10 MIN, CONTACT PHYSICIAN. SKIN: WASH WITH SOPA AND WATER. DO NOT USE SOLVENTS. INHAL: MOVE TO FRESH AIR. INHEST: CALL PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY`

`Steps if Material Released/Spilled`	`DIKE AND PUMP OR SCOOP INTO APPROPRIATE CONTAINERS. SOAK UP IN AN INERT, ABSORBENT MATERIAL`
`Waste Disposal Method`	`IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS`
`Handling and Storage Precautions`	`STORE AT 85 F OR BELOW`

`Respiratory Protection`	`NOT ORDINARILY REQUIRED. NIOSH ORGANIC FUME RESPIRATOR IF VENTILATION IS INADEQUATE`
`Ventilation`	`LOCAL EXHAUST RECOMMENDED MECHANICAL(GENERAL RECOMMENEDED)`
`Protective Gloves`	`IMPERVIOUS(PLASTIC,RUBBER)`
`Eye Protection`	`GOGGLES`
`Other Protective Equipment`	`FOR BRIEF CONTACT, NO SPECIAL PRECAUTIONS OTHER THAN CLEAN BODY-COVERING CLOTHING SHOULD BE NEEDED`
`Supplemental Health/Safety Data`	`DO NOT WEAR CONTACT LENSES WHILE USING OR IN THE VINCINITY IN WHICH THIS PRODUCT IS BEING USED`
`Disposal Code`	`O`

`Container Quantity`	`1`
`Unit of Measure`	`QT`

`Ingredient #`	`01`
`Ingredient Name`	`DIGLYCIDYL ETHER OF BISPHENOL-A`
`CAS Number`	`25068386`
`NIOSH Number`	`N/R`
`Proprietary`	`NO`
`Percent`	`18`
`ACGIH TLV`	`NOT KNOWN`
`Ingredient #`	`02`
`Ingredient Name`	`SILICA`
`CAS Number`	`7631869`
`NIOSH Number`	`N/R`
`Proprietary`	`NO`
`Percent`	`2`
`ACGIH TLV`	`20 MPPEF`
`Ingredient #`	`03`
`Ingredient Name`	`EPICHLOROHYDRIN (ECH)`
`CAS Number`	`106898`
`NIOSH Number`	`N/R`
`Proprietary`	`NO`
`Percent`	`1`
`ACGIH TLV`	`1 PPM`
`Ingredient #`	`04`
`Ingredient Name`	`2,2-[(1-METHYLETHYLIDENE0BIS-(4,1-PHENYLENEOXYMETHYLENE)] BISOXIRANE`
`CAS Number`	`1675543`
`Proprietary`	`NO`
`Percent`	`18`
`Ingredient #`	`05`
`Ingredient Name`	`ALUMINUM LITHIUM SALT OF SILICIC ACID`
`CAS Number`	`12068405`
`Proprietary`	`NO`
`Percent`	`31`
`Ingredient #`	`06`
`Ingredient Name`	`(PHENOXYMETHYL)-OXIRANE`
`CAS Number`	`122601`
`Proprietary`	`NO`
`Percent`	`1`
`Ingredient #`	`07`
`Ingredient Name`	`LIMESTONE`
`CAS Number`	`1317653`
`Proprietary`	`NO`
`Percent`	`31`