ADHESIVE GENERAL PURPOSE

Material Safety Data Sheet

MSDS Preparer's Information

Alternate Vendors

Vendor #5 CAGE

BHMNW

`Specification Number`	`NK`
`Specification Type/Grade/Class`	`NK`
`NRC License Number`	`NR`
`Net Propellant Weight (Ammo)`	`NR`
`Appearance/Odor`	`DARK BROWN LIQUID; SHARP SOLVENT ODOR`
`Boiling Point`	`132 F`
`Melting Point`	`NR`
`Vapor Pressure`	`180MMHG@68`
`Vapor Density`	`2.0`
`Specific Gravity`	`0.91`
`Decomposition Temperature`	`NR`
`Evaporation Rate`	`1.9`
`Solubility in Water`	`SLIGHT`
`Percent Volatiles by Volume`	`64`
`Chemical pH`	`NR`
`Corrosion Rate`	`NR`
`Container Type`	`F`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

`Flash Point`	`0`
`Flash Point Method`	`TCC`
`Lower Explosion Limit`	`2.6`
`Upper Explosion Limit`	`12.8`
`Extinguishing Media`	`CO2, FOAM, DRY CHEMICAL`
`Special Fire Fighting Procedures`	`FIRE FIGHTERS SHOULD BE EQUIPPED WITH SELF CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES INVOLVING THIS MATERIALS`
`Unusual Fire/Explosion Hazards`	`EXTREMELY FLAMMABLE. OVERHEATED, CLOSED CONTAINER ADJACENT TO FIRE COULD EXPLODEDUE TO INTERNAL PRESSURE BUILD UP`

`Stability`	`YES`
`Stability Conditions to Avoid`	`NK`
`Materials to Avoid`	`NA`
`Hazardous Decomposition Products`	`CO, CO2, N, FORMALDEHYDE AND SMOKE PARTICLES WHEN SUBJECTED TO EXCESSIVE HEAT OR FLAME`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`NK`
`LD50 - LD50 Mixture`	`NK`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`SEE OVEREXPOSURE. ALSO DIFFICULT BREATHING & NERVOUS SYSTEM IMPAIRMENT. SOLVENT ASPIRATION INTO THE LUNGS AS A RESULT OF VOMITING MAY CAUSE LUNG DAMAGE WHICH CAN BE HARMFUL OR FATAL`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`NONE`
`Symptoms of Overexposure`	`EYE: SEVERE EYE IRR. VAPOR- ALSO IRRI. SKIN: PROLONGED/REPEATED CONTACT MAY DEFAT, IRRI & DERMATITIS, DRY & CRACKING. INHAL: RESPIRATORY SYS IRRI & TEMP NERVOUSSYS IMPAIR, LIGHT-HEADED, DIZZ, GIDDINESS, DRY OF MOUTH, WEAK, NAUSEA, HEADACHE.HEART, LIVER, KIDNEY, BLOOD DAMAGE. INGES: DIGES SYS IRRI, NAUSEA, DIFF BREATH`
`Medical Cond. Aggrevated by Exposure`	`NK`
`Emergency/First Aid Procedures`	`EYE: FLUSH W/LARGE AMTS OF WATER FOR 10 MIN. GET MED ATTN. SKIN: WIPE OF CONTAMINATION. WASH AFFECTED AREA W/SOAP AND WATER. INHAL: REMOVE TO UNCONTAMINATED AIRCALL A PHYSICIAN. AND IF SWALLOWED: DO NOT INDUCE VOMITING. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY`

`Steps if Material Released/Spilled`	`EXTING ALL IGNITION SOURCES. VENT AREA. OBSERVE PRECAUTIONS FROM ALL SECTIONS. CONTAIN SPILL. COVER W/ABSORBENT MATERIALS AS NEEDED. COLLECT SPILLED MATERIAL USING NON-SPARKING TOOLS. PLACE N A U.S. DEPT OF TRANS APPROVED METAL CONTAINER, AND SEAL`
`Neutralizing Agent`	`NK`
`Waste Disposal Method`	`INCIN ABSORB & BULK PRODUCT AFTER MIXING W/FLAMMABLE MATERIAL IN A LICENSED HAZARDOUS WASTE FACILITYDISPOSAL SHOULD BE U.S. HAZARDOUS WASTE NO. D001 (INGITABLE)`
`Handling and Storage Precautions`	`KEEP AWAY FROM ALL IGNITION SOURCES. VAPORS RELEASED CAN BE IGNITED EASILY. AVOID PROLONGED BREATHING OF VAPORS. USE ONLY IN AREA WITH SUFFICIENT VENT`
`Other Precautions`	`KEEP CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS. KEEP CONTAINER CLOSED WHEN NOT IN USE. IF VENTILATION IS INADEQUATE, WEAR AN APPROVED ORGANIC VAPOR RESPIRATOR. KEEP OUT OF THE REACH OF CHILDREN`

`Respiratory Protection`	`APPROVED ORGANIC VAPOR RESPIRATOR`
`Ventilation`	`MAINTAIN VAPORS BELOW RECOMMENDED EXPOSURE LIMITS`
`Protective Gloves`	`IMPERVIOUS GLOVES`
`Eye Protection`	`CHEMICAL GOGGLES/SAFETY GLASSES`
`Other Protective Equipment`	`NK`
`Work Hygenic Practices`	`NK`
`Supplemental Health/Safety Data`	`THIS PRODUCT CONTAINS TOXIC CHEMICAL OR CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372`
`Disposal Code`	`O`

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`YES`
`Contact Code`	`SLIGHT`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	`TARGET ORGANS: CENTRAL NERVOUS SYSTEM`

`Container Quantity`	`1`
`Unit of Measure`	`QT`

`Volatile Organic Compounds (P/G)`	`0`
`Volatile Organic Compounds (G/L)`	`0`

`Ingredient #`	`01`
`Ingredient Name`	`ACETONE (60-70%)`
`CAS Number`	`67641`
`NIOSH Number`	`AL3150000`
`Proprietary`	`NO`
`Percent`	`70`
`OSHA PEL`	`1000PPM`
`ACGIH TLV`	`750PPM/1000STEL;9293`
`Recommended Limit`	`NK`
`Ingredient #`	`02`
`Ingredient Name`	`PHENOL-FORMALDEHYDE POLYMER (7-13%)`
`CAS Number`	`9003354`
`NIOSH Number`	`1000559AB`
`Proprietary`	`NO`
`Percent`	`13`
`OSHA PEL`	`NK`
`ACGIH TLV`	`NK`
`Recommended Limit`	`NK`
`Ingredient #`	`03`
`Ingredient Name`	`GLYCEROL ESTERS OF ROSIN ACIDS (7-13%)`
`CAS Number`	`8050315`
`NIOSH Number`	`1004468GE`
`Proprietary`	`NO`
`Percent`	`13`
`OSHA PEL`	`NK`
`ACGIH TLV`	`NK`
`Recommended Limit`	`NK`
`Ingredient #`	`04`
`Ingredient Name`	`SALICYLIC ACID (1-5%)`
`CAS Number`	`69727`
`NIOSH Number`	`V00525000`
`Proprietary`	`NO`
`Percent`	`5`
`OSHA PEL`	`NK`
`ACGIH TLV`	`NK`
`Recommended Limit`	`NK`
`Ingredient #`	`05`
`Ingredient Name`	`(ZNCPD) ZINC OXIDE (<2%)`
`CAS Number`	`1314132`
`NIOSH Number`	`ZH4810000`
`Proprietary`	`NO`
`Percent`	`2`
`OSHA PEL`	`15MG/M3 TDUST/5 FUME`
`ACGIH TLV`	`10MG/M3 TDUST; 9293`
`Recommended Limit`	`NK`
`Ingredient #`	`06`
`Ingredient Name`	`NATURAL AND SYNTHETIC RESINS`
`Percent`	`0`
`Ingredient #`	`07`
`Ingredient Name`	`ORGANIC ACID`
`Percent`	`0`
`Ingredient #`	`08`
`Ingredient Name`	`ACRYLONITRILE-BUTADIENE POLYMER (10-20%)`
`CAS Number`	`9003183`
`Percent`	`20`
`Ingredient #`	`09`
`Ingredient Name`	`CURATIVE`
`Percent`	`0`
`Ingredient #`	`10`
`Ingredient Name`	`ANTIOXIDANT (<1%)`
`CAS Number`	`68411461`
`Percent`	`1`