| Flash Point |
104 |
| Flash Point Method |
TCC |
| Lower Explosion Limit |
0.7 |
| Upper Explosion Limit |
N/K |
| Extinguishing Media |
FOAM, CO2, DRY CHEMICAL, WATER FOG, OR CLASS B EXTINGUISHING AGENTS. WATER MAY BE UNSUITABLE, USE TO KEEP CNTNRS COOL |
| Special Fire Fighting Procedures |
WEAR SELF-CONTAINED BREATHING APPARATUS. EVACUATE AREA OF UNPROTECTED PERSONNEL. WEAR PROTECTIVE CLOTHING |
| Unusual Fire/Explosion Hazards |
VAPORS MAY FORM EXPLOSIVE MIXTURE IN AIR AND MAY BE IGNITED BY SPARK, PILOT LIGHTS, ETC. CLOSED CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT |
| Stability |
YES |
| Stability Conditions to Avoid |
HEAT, SPARKS AND OPEN FLAME |
| Materials to Avoid |
IF PRODUCT CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE HYDROGEN GAS |
| Hazardous Decomposition Products |
INCOMPLETE COMBUSTION CAN YIELD CARBON MONOXIDE AND TOXIC VAPORS |
| Hazardous Polymerization |
NO |
| Polymerization Conditions to Avoid |
HEAT, SPARKS AND OPEN FLAMES |
| LD50 - LD50 Mixture |
ORAL LD50 (RAT) IS UNKNOWN |
| Route of Entry: Skin |
YES |
| Route of Entry: Ingestion |
YES |
| Route of Entry: Inhalation |
YES |
| Health Hazards - Acute and Chronic |
SKIN: THIS MATERIAL MAY CAUSE IRRITATION, SENSITIZATION, OR DEFATTING OF SKIN UPON PROLONGED OR REPEATED CONTACT. INHALATION: EXCESSIVE EXPOSURE TO VAPORS OR MISTS CAN RESULT IN HEADACHE, DIZZINESS, NAUSEA AND LOSS OF CONSCIOUSNESS |
| Carcinogenity: NTP |
NO |
| Carcinogenity: IARC |
NO |
| Carcinogenity: OSHA |
NO |
| Explanation of Carcinogenity |
THIS PRODUCT CONTAINS NO KNOWN CARCINOGENS IN REPORTABLE QUANTITIES AS DEFINED BY ACGIH, OSHA, NTP, IARC |
| Symptoms of Overexposure |
SOME REPORTS ASSOCIATE REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. EYES: THIS MATERIAL MAY BE AN EYE IRRITANT |
| Medical Cond. Aggrevated by Exposure |
NONE, WHEN USED IN ACCORDANCE WITH SAFE HANDLING INSTRUCTIONS. SEE SECTION ON CONTROL MEASURES |
| Emergency/First Aid Procedures |
SKIN: PROMPTLY WASH WITH SOAP & WATER. REMOVE & WASH ANY CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH WITH WATER 15 MINUTES & GET MEDICAL AID. INGEST: DO NOT INDUCE VOMITING, KEEP PERSON WARM, QUIET. GET MEDICAL AID. ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. INHAL: REMOVE TO FRESH AIR. IF RESPIRATORY SYMPTOMS DEVELOP, GET MEDICAL AID AT ONCE |
| Steps if Material Released/Spilled |
REMOVE IGNITION SOURCES. VENT AREA. ABSORB SPILL W/ABSORBENT (SAWDUST, VERMICULITE, SAND). PLACE INTO CLOSED CONTAINER. IF LARG SPILL, DIKE AREA TO PREVENT THIS MATERIAL FROM ENTERING WATER SYSTEMS/SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP |
| Neutralizing Agent |
N/K |
| Waste Disposal Method |
TREAT AS HAZARDOUS WASTE (IGNITABLE). DISPOSAL OF MAT'L/CNTNR REQUIRES COMPLIANCE W/LABELING, PACKAGING,RECORDKEEPING STANDARDS. DISPOSE IN ACCORD W/FEDERAL & STATE AGENCIES. GRND HANDLING EQUIPMENT TO PREVENT SPARKS |
| Handling and Storage Precautions |
ID PROLONGED/REPEATED INHALATION OF HEATED VAPOR/SPRAY MIST. KEEP AWAY FROM HEAT/OPEN FLAME. MATERIAL MAY CAUSE SENSITIZATION. DONT WELD ON CNTNRS. DO |
| Other Precautions |
DONT GET IN EYES, ON SKIN OR CLOTHING. DO NOT ALLOW CONTAMINATED CLOTHING TO CONTACT SKIN. KEEP CONTAINERS CLOSED WHEN NOT IN USE, AND PROPERLY LABELED. KEEP OUT OF REACH OF CHILDREN |
| Respiratory Protection |
A CANISTER TYPE RESPIRATOR MUST BE WORN TO PREVENT INHALATION OF VAPORS OR SPRAY MISTS WHEN TLV OR PEL EXCEEDED |
| Ventilation |
GENERAL VENT REQ'D DURING NORMAL USE. LOCAL VENT MAY BE REQ'D DURING SOME OPERATIONS TO KEEP EXPOSURE BELOW TLV/PEL |
| Protective Gloves |
CHEM RESIST, NITRILE, NEOPRENE, RUBBER |
| Eye Protection |
WEAR FACE SHIELD OR CHEMICAL GOGGLES |
| Other Protective Equipment |
WEAR PROTECTIVE CLOHTING TO PREVENT SKIN CONTACT. EYE WASH STATION & SAFETY SHOWERS SHOULD BE AVAILABLE |
| Work Hygenic Practices |
WASH HANDS BEFORE EATING OR SMOKING |
| Supplemental Health/Safety Data |
US EPA RCRA HOTLINE 800-424-9346 OR 202-382-3000 |